Professional Documents
Culture Documents
1. Above what speed 84 Knots til 800' RA. 10. How long should the CL - 2 minutes
Autothrottle APU be operated prior
servos inhibited? to shutdown, after the
APU bleed valve is
2. Above what speed 90 knots
closed?
will the
Autobrakes apply 11. How long should the Operate for a minimum of 1 ( one )
maximum braking APU be operating minute before using as a bleed air
when thrust levers before opening the APU source.
are retarded to bleed valve?
idle during takeoff
12. How long should you 20 seconds, to allow the APU inlet
roll in the classic?
wait after APU door to close.
NG?
shutdown before
3. Are wind gusts Gust velocities and directions are turning the battery
considered in compulsory for tailwind computations, OFF?
limitations? otherwise they are advisory; however,
13. How long should you 1 minute
operations with steady wind
wait before turning on
components at or near 35 knots
engine and APU bleeds Use of WAI on ground after
accompanied by higher gusts require
after de-icing? Use of deicing is prohibited.
careful evaluation of runway surface
Wing Anti-Ice?
conditions and width to ensure the
safety of the operation. 14. How many emergency 8
exits are there?
4. At what braking NIL, as reported by air carrier aircraft on
action is takeoff or any portion of the runway. 15. Is dry running of a No
landing center tank fuel pump
prohibited? allowed? ● Center tank fuel pump switches
must be positioned to OFF when
5. At what braking NIL, or any combination including NIL.
both center tank fuel pump LOW
action is taxiing or
PRESSURE lights illuminate.
towing prohibited?
16. Minimum recommended 100'
6. Can an airplane No
plowed or usable
be dispatched on
runway width?
a revenue flight if
ALL lavatories are 17. Other than for landing, In SEVERE turbulence
inoperative? when are the
autothrottles required
7. Can the aircraft be No
to be disengaged?
dispatched on a
revenue flight if 18. What are the APU ● 90 seconds cooling prior to
the landing gear starter duty cycle second start attempt, and
must remain limitations? ● 5 minutes cooling prior to a
down? third start attempt.
26. What is the freeze -40C 40. What is the maximum pressure 8,400'
point of Jet-A? altitude for takeoff and landing?
41. What is the maximum tailwind 10 Knots
component, including gusts, for
takeoff and landing?
42. What is the maximum tire 195 Knots
speed?
43. What is the Maximum ● NG - 280 KIAS / 0.76 MACH 58. What steps should you Follow turbulent air penetration
Turbulence Penetration ● CL - 280 KIAS / 0.73 MACH accomplish when procedures and set ENGINE START
Speed above 15,000'? operating in or near switches to FLT.
moderate to heavy
44. What is the Maximum 250 KIAS
rain, hail, or sleet?
Turbulence Penetration
Speed below 15,000'? 59. When are you allowed ● Only when directed by the QRH,
to reset a tripped or directed by a procedure in the
45. What is the maximum wind 50 knots steady, 70 knots peak
circuit breaker? AOM, FOM, MEL, or Ops Binder, or
velocity for all takeoffs gusts
when coordinated and approved
and landings?
by maintenance.
46. What is the max landing 128,000 lbs
weight? ● Resetting of tripped fuel quantity
47. What is the max takeoff 154,500 lbs indicator, fuel pump, or fuel pump
weight? control circuit breaker is prohibited.
48. What is the minimum DA/DDA-50', but not less than 60. When can VNAV be After takeoff, initial climb or missed
altitude for disengaging 50' AGL engaged? approach when the flap retraction
the autopilot and is complete.
autothrottle during 61. When is a Cabin Check ● Holdover time has been
approach? required? exceeded or heavy snow is
49. What is the minimum 1000' AGL observed or reported.
altitude for engaging the
autopilot? ● Crew member must inspect both
wing surfaces from cabin ( over
50. What is the minimum ● CL - 400' AGL
wing ) with particular attention to
altitude for LNAV
left wing root.
engagement after takeoff ● NG with LNAV armed
or missed approach? becomes active at 50ft.
● Must takeoff within 5 minutes.
51. What is the minimum 48 minutes, non-reducable
62. When is a Flaps 40 ● Negative [ bracketed ] OPC
ground turn time for a
landing stopping margin under Min(2) for
-800 if the maximum quick
recommended? Flaps 30, OR
turnaround weight is
exceeded for the brakes?
● Reported braking action is less
52. What is the minimum MU Takeoff or landing is not than GOOD, OR
value for takeoff and authorized if the most current
landing? runway friction Mu report ● Weather is at or near minimums
includes a value of 20 or less for the approach to be flown.
for any section of the runway.
63. When is Engine Anti- In icing conditions or when icing
53. What is the minimum 1,675# in the respective wing ice required? conditions are anticipated:
onboard fuel for ground tank - During climb and cruise above
operation of the electric -40C, and
hydraulic pumps? - in any temperature during
54. What is the normal AC 400Hz +/-10Hz descent
frequency? 64. When is the use of Do not use LNAV if the message
55. What is the normal battery 23-30V DC LNAV prohibited? "UNABLE REQD NAV PERF-RNP" is
voltage range? active.
56. What is the requirement Only when directed by a QRH 65. When is use of WiFi On the flight deck, when the
for starting the APU while procedure or by the OPC. devices prohibited? engines are operating for the
airborne? purpose of flight.
57. What is the safety relief ● NG = 9.10 psi 66. When is verification of Prior to departure with passengers.
differential pressure? ● CL = 8.65 psi the overwing exit
handle cover
required?
67. When must hydraulic System A be depressurized? During aircraft towing
68. When must oil quantity reading be taken? Oil limitations are based on flight deck oil quantity indicator
readings within 30 minutes of engine shutdown.
69. When must the APU bleed air valve be closed? ● When ground air is connected and the ISOLATION VALVE is
OPEN, OR
Note: the APU bleed valve may be OPEN during engine start
provided the #1 engine power is not above idle.