Professional Documents
Culture Documents
16
Manual transmission 715.5
1 Sealing gasket
2 Sealing ring
3 Back closing cover
4 Screw
W26.45-0009-11
Install
1 Remove the back closing cover (3) Clean the sealing surface. AR26.30-B-3001TC
2 Remove the driven shaft and the driven flange
on the secondary shaft
3 Install the power take-off AR26.45-B-0001TC
4 Install the driven flange on the secondary Observe for the correct positioning of the
shaft and the driven shaft sealing ring.
5 Install the compressed air pipe in the power To install the compressed air pipe from
plug socket drive cylinder the power plug socket pneumatic system in
vehicles that did not previously have the
power plug socket, it is necessary to cut the
electropneumatic valve air tube in the gearbox
in an average position and install: The "T"
connection and the coupling mouth system
that are part of the power plug socket
installation kit.
6 Perform the parametrization on the ADM GF54.21-B-0002-01A
module