Professional Documents
Culture Documents
HARNESSES
Dynamic Performance
Harnesses are subject to a performance test in which a shock load, exceeding that
likely to be experienced in use, is applied. In addition, the test will indicate the harness’
response during use, specifically the angle at which the wearer will be held in the event
of a fall.
In preparation for testing, the harness is fitted to a 100 kg solid torso dummy and
connected by the harness attachment to a 2m length of 11mm mountaineering rope,
chosen specifically to generate a known force in the harness in the event of a fall. This
rope is attached to a secure anchor point and the dummy is released over a distance of
4m. This test is conducted twice on each harness attachment, once from a head-up
position and once from a head-down position (i.e. with the dummy upside down on
release). To pass the test, the harness must hold the dummy following both drops, with
the dummy held in a position that does not exceed 50° from the upright position. These
tests are conducted on each of the harness’ attachment points.
Static Strength
Products’ tensile tests are based on a factor of safety relative to the 6 kN expected
during use. Harnesses are subjected to a 15 kN tensile force applied upward followed
by a 10 kN force applied downward. Lanyards are subjected to either 22 kN or 15 kN
applied between the attachment points, depending on the material used. The
application of an increased force tests the effects of aging (e.g., abrasion, wear and
tear) on the lanyard’s protective capacity. Tensile forces are usually applied and held for
at least 3 minutes to ensure the breaking strength of the product exceeds the force
specified by the standard.
Corrosion Resistance
Metallic components used in fall protection equipment are subjected to a neutral salt
spray test to determine whether the product can provide a minimum resistance to
environmental corrosion (e.g., rust). Products are held in a sealed chamber filled with a
saltwater mist, which can cause untreated metals to rust. Products are subjected to
either 24 or 48 hours of exposure and examined thereafter for signs of rust and to
assess whether each device can continue to function properly.