1) The document is a work sheet for an engine repair on a Volvo-480DL machine with an engine serial number of HMR.
2) The complaint was a broken inlet valve spring, so the repair involved replacing the inlet valve spring.
3) The procedure specifies adjusting the camshaft position by aligning dash marks and setting the inlet valve clearance to 0.20 mm and exhaust valve clearance to 0.80mm.
1) The document is a work sheet for an engine repair on a Volvo-480DL machine with an engine serial number of HMR.
2) The complaint was a broken inlet valve spring, so the repair involved replacing the inlet valve spring.
3) The procedure specifies adjusting the camshaft position by aligning dash marks and setting the inlet valve clearance to 0.20 mm and exhaust valve clearance to 0.80mm.
1) The document is a work sheet for an engine repair on a Volvo-480DL machine with an engine serial number of HMR.
2) The complaint was a broken inlet valve spring, so the repair involved replacing the inlet valve spring.
3) The procedure specifies adjusting the camshaft position by aligning dash marks and setting the inlet valve clearance to 0.20 mm and exhaust valve clearance to 0.80mm.
Complaint- Spring Broken(Inlet) Replacement of Inlet Valve Spring
Tappet Setting Procedure-
Rotate the camshaft to adjust the rocker arms. The dash marking on the camshaft must be positioned between the two dash marks on the bearing housing cap.
Clearance-Inlet Valve- 0.20 mm , Exhaust Valve-0.80mm