Professional Documents
Culture Documents
Correct Answer: 10: 1. The Default Value of "Target Scope" For Static Route Is
Correct Answer: 10: 1. The Default Value of "Target Scope" For Static Route Is
Correct Answer: 10
3.Router is connected to 10.10.10..0/24 (public) and 10.1.1.0/24 (local) networks. There are
two routes in the routing table.
0 dst-addr=0.0.0.0/0 gateway=10.10.10.10
1 dst-addr=0.0.0.0/0 gateway=10.10.10.11 routing-mark=server_traffic
Through which gateway will a client, with an IP address of 10.1.1.12, establish a connection
to internet?
Which gateway will be used for a packet with destination address 10.1.5.126?
Correct Answer: A. 10.1.1.2
6. ECMP Provides:
Correct Answer: D. per src/dst address pair load balancing to multiple gateways
7. If a client network subnet is added to the OSFP STUB area. is the network considered
external?
Correct Answer: False
8. It is possible to create a configuration where VLAN and PPTP interface are bridged
together.
10. Consider the following diagram, we want to communicate from a device on LAN1 to a
device on LAN2. Assuming that all necessary configurations are already included on R2,
which of the following configurations in R1 would enable this communication?
12. Which gateway will be used to send packet with destination IP address 10.1.1.6
/ip route
add disabled=no distance=1 dst-address=192.168.1.0/24 gateway=1.1.1.1
add disabled=no distance=1 dst-address=192.168.1.0/25 gateway=2.2.2.2
add disabled=no distance=1 dst-address=192.168.0.0/16 gateway=3.3.3.3
what routing mark will the packet have after passing the forward chain?
17. a mikrotik system administrator implemented OSPF routing protocol in the network. but
realized that he has a static route on the routes. What can be done to make the static route
work as a failover whenever the dynamic routing protocol fails
Correct Answer: C. He should increase the administrative distance of the static route
18. a BGP peer, must be one hop away from our router. That is, a BGP Peer must have layer
2 visibility of our router to establish the BGP connections
21. router A And B are both running as PPPoE server on different broadcast domains of your
network. It is possible to set router A to use "/ppp secret" accounts from router B to
authenticate PPPoE customers
24. A mikrotik PPOe server canbe used only within a broadcast domain, that is, users can not
run PPPoE protocol if there is a router that splits broadcast domain between the customer and
that PPPoE server.
You cannot use OSPF and RIP routing protocols simultaneously on the RouterOS
25. In OSPF interface configuration what effect wil a "passive=yes" option have on a specific
interface?
Correct Answer: C. it will prevent router learned through the interface from being
listed in the routing table