Professional Documents
Culture Documents
Psychrometrics Problems
Psychrometrics Problems
Example 1. Air at 60 C dry bulb temperature and 27.5 C wet bulb temperature, and a humidity ratio of 0.01 kg
water/kg dry air is mixed with water adiabatically and is cooled and humidified to a humidity ratio of 0.02 kg
water/kg dry air. What is the final temperature of the conditioned air?
Given
Inlet: dry bulb temperature = 60C
wet bulb temperature = 27.5 C
Initial humidity ratio W 1 = 0.01 kg water/kg dry air
Final humidity ratio W 2 =0.02 kg water/kg dry air
Solution
From Table A.4.2, latent heat of vaporization at 27.5 C = 2436.37 kJ/kg
Example 2. Calculate the rate of thermal energy required to heat 10 m 3 /s of outside air at 30 C dry bulb
temperature and 80% relative humidity to a dry bulb temperature of 80 C.
Solution
1. Using the psychrometric chart, we find at 30 C dry bulb temperature and 80% relative humidity, the enthalpy
H1 = 85.2 kJ/kg dry air, humidity ratio W1 = 0.0215 kg water/kg dry air, and specific volume V1= 0.89 m3 /kg
dry air. At the end of the heating process, the dry bulb temperature is 80 C with a humidity ratio of 0.0215 kg
water/kg dry air. The remaining values are read from the chart as follows: enthalpy H 2 =140 kJ/kg dry air;
relative humidity φ2 =7%.
2.
Example 3. In efforts to conserve energy, a food dryer is being modified to reuse part of the exhaust air along
with ambient air. The exhaust air flow of 10 m 3/s at 70 C and 30% relative humidity is mixed with 20 m 3/s of
ambient air at 30 C and 60% relative humidity. Using the psychrometric chart, determine
the dry bulb temperature and humidity ratio of the mixed air.
Solution
1. From the given data, locate the state points A and B, identifying the exit and ambient air as shown on the
skeleton chart ( Fig. E9.3 ).
2. Join points A and B with a straight line.
3. The division of line AB is done according to the relative influence of the particular air mass. Since the mixed
air contains 2 parts ambient air and 1 part exhaust air, line AB is divided in 1:2 proportion to locate point C.
Thus, the shorter length of line AC corresponds to larger air mass.
4. The mixed air, represented by point C, will have a dry bulb temperature of 44 C and a humidity ratio of 0.032
kg water/kg dry air.
Example 4. Heated air at 50 C and 10% relative humidity is used to dry rice in a bin dryer. The air exits the bin
under saturated conditions. Determine the amount of water removed per kg of dry air.
Solution
1. Locate point A on the psychrometric chart, as shown in Figure. Read humidity ratio 0.0078 kg water/kg dry
air.
2. Follow the constant enthalpy line to the saturation curve, point B.
3. At point B, read the humidity ratio 0.019 kg water/kg dry air.
4. The amount of moisture removed from rice 0.019 – 0.0078 = 0.0112 kg water/kg dry air.
On the humidity chart follow down the wet-bulb line for a temperature of 20°C until it meets the dry-bulb
temperature line for 25°C. Examining the location of this point of intersection with reference to the lines of
constant relative humidity, it lies between 60% and 70% RH and about 4/10 of the way between them but
nearer to the 60% line. Therefore the RH is estimated to be 64%. Similar examination of the enthalpy lines
gives an estimated enthalpy of 57 kJ kg-1, and from the volume lines a specific volume of 0.862 m3 kg-1.
Once the properties of the air have been determined other calculations can easily be made.
On heating, the air condition moves, at constant absolute humidity as no water vapour is added or subtracted, to
the condition at the higher (dry bulb) temperature of 40°C. At this condition, reading from the chart at 40°C and
humidity 0.0125 kg kg-1, the enthalpy is 73 kJ kg-1, specific volume is 0.906 m3 kg-1 and RH 27%.
If the air is used for drying, with the heat for evaporation being supplied by the hot air passing over a wet solid
surface, the system behaves like the adiabatic saturation system. It is adiabatic because no heat is obtained from
any source external to the air and the wet solid, and the latent heat of evaporation must be obtained by cooling
the hot air. Looked at from the viewpoint of the solid, this is a drying process; from the viewpoint of the air it is
humidification.
Using the psychrometric chart, the inlet air condition shows the humidity of the drying air to be 0.01 kg kg-1 and
its specific volume to be 0.96 m3 kg-1. Through the dryer, the condition of the air follows a constant wet-bulb
line of about 27°C , so at 35°C its condition is a humidity of 0.0207kg kg-1.
So each kg, i.e. 0.96 m3, of air passing will remove 0.0107kg water,
If air is cooled, then initially its condition moves along a line of constant humidity, horizontally on a
psychrometric chart, until it reaches the saturation curve at its dew point. Further cooling then proceeds down
the saturation line to the final temperature, with water condensing to adjust the humidity as the saturation
humidity cannot be exceeded.
EXAMPLE 8. Relative humidity of air leaving a dryer
The air emerging from a dryer, with an exit temperature of 45°C, passes over a surface which is gradually
cooled. It is found that the first traces of moisture appear on this surface when it is at 40°C. Estimate the
relative humidity of the air leaving the dryer.
On the psychrometric chart, the saturation temperature is 40°C and proceeding at constant humidity from this,
the 45°C line is intersected at a point indicating:
relative humidity = 76%
In dryers, it is sometimes useful to reheat the air so as to reduce its relative humidity and thus to give it an
additional capacity to evaporate more water from the material being dried. This process can easily be followed
on a psychrometric chart.
From the psychrometric chart the humidity of the initial air is 0.0062 kg kg-1, specific volume is 0.834 m3 kg-1,
and enthalpy 35 kJ kg-1. Proceeding at constant humidity to a temperature of 140°C, the enthalpy is found to be
160 kJ kg-1. Proceeding along a wet-bulb line to an RH of 60% gives the corresponding temperature as 48°C
and humidity as 0.045 kg kg-1.
Reheating to 140°C keeps humidity constant (0.045 kg kg-1 )and enthalpy goes to 268 kJ kg-1.
Consideration of psychrometric charts, and what has been said about them, will show that they can be used for
calculations focused on the air, for the purposes of air conditioning as well as for drying.
Assuming that the air changes are calculated at the conditions in the working space.
Mass of air to be conditioned = (1650 x 6)/0.827 = 11,970 kg h-1
Water removed per kg of dry air DY = 0.0266 - 0.0085 = 0.018 kg kg-1
Mass of water removed per hour = 11,970 x 0.018 = 215 kg h-1
Problem 1. Atmospheric air at 760 mm Hg is at 22 C dry bulb temperature and 20 C wet bulb temperature.
Using the psychrometric chart, determine:
a. Relative humidity.
b. Humidity ratio.
c. Dew-point temperature.
d. Enthalpy of air per kg dry air.
e. Volume of moist air/kg dry air.
Problem 2. Moist air flowing at 2 kg/s and a dry bulb temperature of 46 C and wet bulb temperature of 20 C
mixes with another stream of moist air fl owing at 3 kg/s at 25 C and relative humidity of 60%. Using a
psychrometric chart, determine the (a) humidity ratio, (b) enthalpy, and (c) dry bulb temperature of the two
streams mixed together.
Problem 3. Air at a dry bulb temperature of 20C and relative humidity of 80% is to be heated and humidified to
40C and 40% relative humidity. The following options are available for this objective:
(a) by passing air through a heated water-spray air washer;
(b) by preheating sensibly, and then passing through a water spray washer with recirculated water until relative
humidity rises to 95% and then again heating sensibly to the final required state. Determine for (a) and (b) the
total heating required, the make-up water required in water-spray air washer, and the humidifying efficiency of
the recirculated spray water.
Problem. 4 Moist air at 35 C and 55% relative humidity is heated using a common furnace to 70C. From the
psychrometric chart, determine how much heat is added per m3 initial moist air and what the final dew-point
temperature is.
Problem 5. A water-cooling tower is to be designed with a blower capacity of 75 m 3/s. The moist air enters at
25C and wet bulb temperature of 20 C. The exit air leaves at 30 C and relative humidity of 80%. Determine the
flow rate of water, in kg/s, that can be cooled if the cooled water is not recycled. The water enters the tower at
40C and leaves the tower at 25C.
Problem 6. Air is at a dry bulb temperature of 20C and a wet bulb temperature of 15C. Determine the
following properties from a psychrometric chart.
a. Moisture content
b. Relative humidity
c. Enthalpy
d. Dew point
e. Specific volume
Problem 7. Air at a dbt (dry bulb temprature) of 30 C and a relative humidity of 30% is conveyed through a
heated dryer where it is heated to a dbt of 80 C. Then it is conveyed through a bed of granular pet food to dry it.
The air exits the dryer at a dbt of 60 C. The exit air is again heated to 80 C and conveyed through another dryer
containing another batch of pet food. The exit air from the second dryer leave at saturation. Clearly show the
paths of air, starting from the ambient air to the saturated air exiting the second dryer on a copy of a
psychrometric chart. Determine the amount of water removed in the first and second dryer per kg of dry air.