Professional Documents
Culture Documents
3. A measure of cohesive strength of cross-linkage that occurs between molecules of gelatin is known
as
a) Gel strength
b) Bloom strength
c) Both a and b
d) None of the above
5. If an average weight of tablet is 130 mg or less, then the acceptable percentage range for weight
variation test will be ± _____
a) 5%
b) 10%
c) 7.5%
d) 20%
7. The dispensing pharmacist usually blends potent powders with a large amount of diluent by
a) Spatulation.
b) Sifting.
c) Trituration.
d) Geometric dilution.
____________________________________________________________________________
MUKARRAM ANEES AWAN R. Ph.
M.Phil. Pharmacy; Pharm-D (UVAS)
PHARMACIST (BS-17), P&SHD, PUNJAB.
Ph. 0302-6162799
2
11. Which of the following shows the type of parenteral dosage form?
a) Pressurized metered-dose inhaler
b) Lotion
c) Tablet
d) Transdermal implant
a) Sugar coating
b) Film coating
c) Enteric coating
d) Sealing coating
13. From the below options which will be the most widely used form of dosage?
a) Emulsion
b) Solutions
c) Tablets
d) Powders
14. Fluidextracts contain alcohol as?
a) Solvent
b) Preservative
c) Both a & b
d) None
21. Syrups NF is
a) Self preserving
b) A supersaturated solutions
c) High unstable
d) Flavored and preserved
____________________________________________________________________________
MUKARRAM ANEES AWAN R. Ph.
M.Phil. Pharmacy; Pharm-D (UVAS)
PHARMACIST (BS-17), P&SHD, PUNJAB.
Ph. 0302-6162799
4
24. The HLB system is most applicable for the classification of which surfactants?
a) Anionic
b) Ampholytic
c) Cationic
d) Nonionic
a) Galenicals
b) Parenteral
c) Plant Vehicles
d) Generics
____________________________________________________________________________
MUKARRAM ANEES AWAN R. Ph.
M.Phil. Pharmacy; Pharm-D (UVAS)
PHARMACIST (BS-17), P&SHD, PUNJAB.
Ph. 0302-6162799