Professional Documents
Culture Documents
47. The warning is triggered _____ the flight phase. 59. A toolkit contains a _____.
A. as soon as A. dolly, a mallet and a soldering iron
B. whatever B. wrench, a lathe and an Allen key
C. once C. wire stripper, pliers and calipers
D. thus D. drill bit, a ring spanner and a milling machine
48. Fill the tank _____ the high level is reached. 60. Mix the fluids _____.
A. thoroughly
A. unless
B. evenly
B. if
C. until C. at equally spaced intervals
D. however D. back and forth
49. The generator is disconnected _____ an overload. 61. If unsatisfactory, do the _____ step again.
A. despite A. prevented
B. in the event of B. previous
C. however C. subsequent
D. provided D. next
50. The blower fan is inoperative _____ the 62. _____ and sign the job card.
equipment may overheat. A. Fill
A. because B. Record
C. Replenish
B. although
D. Fill in
C. so
D. due to 63. De-energize the aircraft electrical _____.
51. Insert a _____ on the nose landing gear steering box. A. network
A. stud B. net
B. cotter pin C. harness
C. safety pin D. loop
D. grommet 64. _____ the cover with QAD fasteners.
52. Adjust the upper door _____. A. Fix
A. socket B. Safety
B. hinge C. Keep
C. loom D. Secure
D. gasket 65. Engine oil must be checked and _____ 5 minutes after
53. Torque the double hexagon _____ to the given value. each shutdown.
A. nut A. completed
B. lug B. filled
C. washer C. refueled
D. sleeve D. replenished
66. Install the front spar access panels. This is ATA
54. The two pipes are connected by an _____ union.
chapter No.
A. hose
B. O-ring A. 49 - APU
C. insert B. 28 - fuel
D. elbow C. 29 - hydraulic power
D. 21 - air conditioning
55. Lubricate the _____ of the screw.
67. Make sure that the pressure shown on the pressure
A. thread
gage of the cylinder is more than the minimum
B. pitch
pressure found. This is ATA chapter No.:
C. shank
D. collar A. 24 - elec. power
B. 35 - oxygen
56. A _____ is designed to firmly hold a part as you work C. 26 - fire protection
on it. D. 21 - air conditioning
A. drill
68. Loosen the clamp and move the sleeve away from the
B. vise
smoke extraction fan. This is ATA chapter No:
C. clamp
A. 49 - APU
D. bench
B. 21 - air conditioning
57. A _____ is used to cut through thick materials. C. 36 - pneumatic power
A. sling D. 72 - engine
B. lathe 69. Install blanking plugs on the open discharge port of
C. file
the HMU and on the open ends of the fuel supply
D. grinder
tube. This is ATA chapter No:
A. 26 - fire protection
B. 49 - APU
C. 36 - pneumatic power
D. 72 - engine
243. You _____ wear protective clothing. 255. _____ movement caused by the rudder pedals is
transmitted from the steering crank to the quadrant.
a. shall
b. could a. None
c. may b. Any
d. will c. Some
d. Several
244. The Airworthiness Directive is _____.
256.Do not hit the inlet plenum with your hands or your
a. recommended
b. mandatory tools. _____ damage to the plenum can occur.
c. optional a. The
d. unreliable b. A
c. -
245. Choose the correct group of words. d. Any
a. bristle soft non-metallic brush
257._____ windshield wiper is controlled with the WIPER
b. non-metallic soft bristle brush
c. soft brush non-metallic bristle control switch.
d. brush soft non-metallic bristle a. A
b. -
246. Choose the correct group of words. c. Both
a. cabin system test and cockpit d. Each
b. test system cockpit and cabin
258.The duct leak detection system uses thermal switches
c. cabin system and cockpit test
d. cockpit and cabin system test to find _____ leak in a bleed air duct.
a. some
247. Choose the correct group of words. b. -
a. main air extraction duct c. the
b. duct air main extraction d. a
c. main air duct extraction
259. Only one CPC operates its system at a time, with the
d. extraction duct main air
_____ system on standby.
248. Choose the correct group of words. a. other
a. cargo forward compartment ceiling panels b. each
b. cargo ceiling forward compartment panels c. together
c. forward ceiling compartment cargo panels d. both
d. forward cargo compartment ceiling panels
260. Tailwinds, or winds with tailwind components, _____
249. Choose the correct group of words. affect ground operation of engines.
a. 100 ATA specification, 29 revision a. adverseless
b. ATA specification 100, revision 29 b. adverse
c. ATA specification 29, revision 100 c. adversely
d. revision 29-100 ATA specification d. adversity
250. The windshield anti-icing system makes sure that the 261.The equipment and furnishings are installed in the
crew can see _____ the windshield and side windows. cargo compartments for the _____ and safety of the
a. in cargo.
b. through a. handler
c. around b. handling
d. over c. handled
251. The nominal temperature regulation is _____ 35° d. handle
and 42°C.
a. from
b. within
c. between
d. below
351. The pump _____ to pressurize both systems. 362. Open, safety and tag these _____.
a. can a. electrical connectors
b. may b. circuit breakers
c. is able c. bonding jumpers
d. must d. terminal covers
352. A rapid movement _____ cause damage to 363.Pull the oxygen container forward until the _____ are
the equipment. released.
a. should a. safety pins
b. could b. studs
c. need c. cotter pins
d. must d. retainers
353. The escape slide _____ be disarmed before 364. Remove the screws, the _____ and the handle.
opening the passenger door. a. collars
a. could b. washers
b. may c. studs
c. has d. hi-locks
d. is to 365. Remove and discard the _____ from the nut.
354. When you set the switch to ON, the cabin lights _____ a. lockwire
come on. b. link
a. can c. loop
b. shall d. lanyard
c. will 366. Put _____ under the nose and main gear wheels.
d. must a. wedges
b. chocks
c. shims
d. shocks
480. If only one actuator operates, the status message 491.The current speed and altitude are displayed on a
PEDAL STEERING will come _____ view on the digital _____.
EICAS. a. reader
a. to b. readout
b. on c. readup
c. into d. reading
d. in 492. _____ goggles, protective gloves and face mask.
481. The contact must be seated squarely _____ the cable a. Wear
dielectric or insulator. b. Carry
a. under c. Support
b. against d. Retain
c. over 493.The OFF legend of the IDG will _____ if a correct reset
d. near of the disconnect mechanism has occurred.
482. Pressing the pushbutton switch at _____ a. lighten
attendant station will turn on all the cabin lights. b. come on
a. these c. go off
b. a d. de-energize
c. some 494.The active CPC _____ control signals through a bus
d. any to the outflow valve.
483. Charge the cylinder until the pressure is _____ than a. sets
1850 psi. b. sends
a. greater c. releases
b. most d. receives
c. less 495._____ the operational test of the engine fire
d. equal extinguishing.
484. Apply _____ water to the windshield to test the a. Ensure
windshield wiper system. b. Perform
a. the c. Allow
b. a d. Provide
c. - 496.This temperature selection will _____ the heat probe
d. any stabilize at a temperature slightly below the nominal
485. The elevator hydraulic actuation is ensured by 2 close temperature.
electro-hydraulic servo controls on _____ surface. a. do
a. the b. let
b. each c. permit
c. all d. cause
d. a 497.The failure data _____ and you can _____ it on the
486. The MLI is a glass-reinforced plastic rod. At _____ MCDU after each flight.
end of the rod is a magnet. a. stored / see
a. one b. is storing / see
b. a c. is stored / to see
c. both d. is stored / see
d. an 498.If there _____ a warning signal, the MASTER WARN
487. The test may be _____ at any time by _____ the lights _____ and a continuous repetitive chime _____.
line select key next to the ABORT prompt. a. has / flash / hears
a. aborted / pressed b. are / flash / is heard
b. aborted / pressed c. is / flash / is heard
c. aborting / pressing d. is / flashes / hearing
d. aborted / pressing 499. The surfaces _____ by three types of computer _____
488. The control surfaces must be _____ after installation. on their functions.
a. rigged a. controlled / depending
b. rig b. are controlled / depending
c. rigging c. control / depended
d. rigger d. are controlling / depending
489. Handsets are installed at all the cabin _____ stations. 500. Mechanically and hydraulically _____ doors close
a. attendants _____ the aerodynamic contours when the
b. attendants' landing gear retracts.
c. attendants's a. operated / to make
d. attendant's b. operating / to make
c. operated / made
d. operating / making
a. >6.5 mm
b. >12.5 mm
779. To do the inspection of the forward shackles, remove
the shackles on one side, with the shackles of the
opposite side installed. Inspect the _____ shackles.
a. left then right
b. left and right
c. forward then rear
d. forward and rear
780. Do not remove the soft liner from the windshield. If
it is necessary to replace the soft liner, you must remove
the windshield and send it to the vendor. If the inner
surface of the windshield is damaged:
a. repair it
b. replace it
c. send the whole assembly to the supplier
d. contact the supplier
781. Be careful when you go into the center wing box. You
can cause damage to the carbon rods. You may cause
damage because of:
a. limited access
b. composite materials
c. sharp tools
d. incorrect procedures
782. To prevent contamination of the cleaning agent, put
the clean agent to the cloth. You should always:
a. use a new cloth
b. use fresh cleaning agent
c. pour the cleaning agent on the cloth
d. replace the plug on the container
783. Raceways contain some electrical cables. They are
made in U-sections from aluminum alloy with a nylon
coating. The mounting brackets are installed on the
forward face of the front spar and the aft face of the rear
spar. Wiring is routed _____ .
a. along the wing trailing edge
b. throughout the wing
c. along the wing leading edge
d. along the wing leading and trailing edges.
816. The crossbeams _____ _____ holes. 827. You _____ not use any sharp tools.
a. have / lightened a. would
b. has / lightened b. should
c. have / lightening c. will
d. has / lightening d. may
817. The floor panels _____ of honeycomb core, which 828. Ground locks _____ be installed on all the gears.
_____ between sheets of composite materials. a. could
a. are made / is bonded b. will
b. are made / are bonded c. must
c. made / are bonded d. need
d. are made / bonds