Professional Documents
Culture Documents
Unior d.d.
Kovaška cesta 10
3214 Zreče, Slovenia
T: +386 3 757 81 00
F: +386 3 576 26 43 uniortools.com
sales@unior.com
www.uniortools.com
TOOL ASSEMBLY... WHERE TO APPLY ... USAGE INSTRUCTIONS ...
ENG SLO
On the track bush (1) place the Na stezno pušo (1) namestite
4
D 1 pushing bush (2) and on this put the
track nut (3) with a spindle (4). 1 potisno pušo (2), ter nanju privijte
stezno matico (3) z vretenom (4).
3
You can place the track bush: into Stezno pušo lahko namestite: v
2 2
A
1 2 Ø
3 the slot on the bearing race (A) or
under the bearing race (B).
utor na ležajnem obroču (A), ali
pod ležajni obroč (B).
2
Choose the right size of the track Izberite pravilno velikost stezne
1 B 3 bush (D) regarding the outer
diameter of the bearing race (Ø). 3 puše (D) glede na zunanji premer
ležajnega obroča (Ø).
If you pull the bearing race from the Če snemate ležajni obroč iz
4 4
S19
S27 wheel hub you must place on the pesta kolesa, morate na vreteno
spindle also suitable support for the namestiti tudi ustrezen podstavek
spindle. The support is not necessary vretena. Pri snemanju ležajnega
by pulling the bearing race from the obroča iz gredi, podstavka ne
shaft. potrebujete.
4 5 6
Put the race puller over the bearing Snemalec namestite čez ležajni
Start to turn the spindle (S19) and Vreteno začnite privijati (S19), ter s
8
Remove the bearing race from the
puller. 8 obroč.