Professional Documents
Culture Documents
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
WARNING: BE CAREFUL WHEN YOU USE CONSUMABLE MATERIALS. OBEY THE MATERIAL MAN
UFACTURER'S INSTRUCTIONS AND YOUR LOCAL REGULATIONS.
CAUTION: DURING STORAGE OR PARKING PERIODS, DO NOT STOP OR CHANGE THE MAINTE
NANCE PROGRAM UNLESS IT WAS AGREED BY THE LOCAL AUTHORITIES. THE MAI
NTENANCE CALENDAR CLOCK CONTINUES DURING THESE PERIODS.
IF YOU DO THE AMM STORAGE OR PARKING PROCEDURES CORRECTLY, AND IF YO
U HAVE THE AGREEMENT OF THE LOCAL AUTHORITIES, IT IS NOT NECESSARY TO
DO ALL THE SCHEDULED MAINTENANCE TASKS (SUCH AS MPD TASKS) IMMEDIAT
ELY DURING THE STORAGE/PARKING PERIOD. YOU CAN WAIT UNTIL THE END OF
THE PERIOD. BUT YOU MUST DO THEM ALL BEFORE THE NEXT FLIGHT.
QT
REFERENCE DESIGNATION
Y
No specific 1 ACCESS PLATFORM 15M (49 FT) - ADJUSTABLE
No specific 1 ACCESS PLATFORM 3M (10 FT)- ADJUSTABLE
No specific AR CHOCK - WHEEL(S)
No specific AR TAPE - ADHESIVE
98D27803000000 1 LOCKING TOOL-FLAP SLAT LEVER,INT. POSITION
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
B. Consumable Materials
REFERENCE DESIGNATION
02ABA1 Phosphate Ester Hydraulic Fluid-General Power - -
03HBD9 Synthetic Ester base Grease-General Purpose Low Temp -
03JCA9 Silicone base Grease-Mechanisms and Seals - -
03QDB1 Dry lubricant-Anti Seizing PTFE Loaded -
08BBB1 Non Aqueous Cleaner-- Petroleum Based -
12AGC2 Corrosion Preventive Compound-- Soft Film System
14HMB1 Film-- Waterproof Barrier -
C. Referenced Information
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
REFERENCE DESIGNATION
Ref. 05-27-10-200-001-A GENERAL VISUAL INSPECTION OF NOSE GEAR AND NOSE
GEAR DOORS (EWIS)
Ref. 05-27-30-200-001-A General Visual Inspection of LH/RH Main Landing Gear inclu
ding Cylinder and Secondary Doors (EWIS)
Ref. 05-27-30-200-002-A GENERAL VISUAL INSPECTION OF MAIN LANDING GEAR CY
LINDER DOOR (EWIS)
Ref. 05-27-30-200-003-A GENERAL VISUAL INSPECTION OF MAIN LANDING GEAR SE
CONDARY DOOR (EWIS)
Ref. 05-27-30-200-004-A GENERAL VISUAL INSPECTION OF MAIN LANDING GEAR M
AIN DOORS (EWIS)
Ref. 07-12-00-582-001-A Jacking of the Nose Landing Gear
Ref. 07-12-00-582-002-A Jacking of the Main Landing Gear
Ref. 09-10-00-584-002-A Towing by the Nose Landing Gear from the Front with a Tow
bar
Ref. 10-10-00-550-801-A Parking and Storage Procedure
Ref. 10-11-00-555-015-A Procedure for the Installation of Wheel Chocks on Aircraft
Ref. 10-20-00-556-001-A Mooring of Aircraft without Weight and Balance Provision on
the Landing Gear Legs
Ref. 10-20-00-556-001-A01 Mooring of Aircraft with Weight and Balance Provision on th
e Landing Gear Legs
Ref. 12-11-28-650-003-A Pressure Refuel with Automatic Control
Ref. 12-11-28-650-004-A Pressure Refuel with Manual Control
Ref. 12-14-32-200-001-A Inspection of the MLG Shock Absorbers Before Flight
Ref. 12-14-32-200-002-A Check of the NLG Shock Absorber Bottoming
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
REFERENCE DESIGNATION
Ref. 12-22-27-640-805-A Lubrication of THS Mechanical Control Chains and Rear Cabl
e (Area of Tension Regulator) with Grease Mat. No. 04-037
Ref. 12-22-32-640-001-A Lubrication of Main Landing Gear and Doors
Ref. 12-22-32-640-002-A Lubrication of Nose Landing Gear and Doors
Ref. 12-22-53-640-001-A Lubrication of Trimmable Horizontal Stabilizer Bearings and
Attachment Fittings with Grease Mat. No. 04-004 (or Greas
e Mat. No. 03HBD9)
Ref. 12-22-53-640-002-A Lubrication of Trimmable Horizontal Stabilizer Bearings and
Attachment Fittings with Grease Mat. No. 04-037 (or Greas
e Mat. No. 03GBC1)
Ref. 12-22-55-640-001-A Lubrication of Rudder Hinge Bearing No. 6 with Grease Mat.
No. 04-004 (or Grease Mat. No. 03HBD9)
Ref. 12-22-55-640-002-A Lubrication of Rudder Hinge Bearing No. 6 with Grease MAT.
No. 04-037 (or Grease MAT. No. 03GBC1)
Ref. 12-24-34-600-001-A Bleeding of the Standby Air Data System
Ref. 12-32-28-281-001-A Drain Water Content
Ref. 12-32-28-281-003-A Sample Fuel for Microbiological Contamination Analysis
Ref. 12-32-28-281-806-A Test Of Fuel For Microbiological Contamination During Parki
ng And Storage When Biocide Is Not Available
Ref. 12-34-24-869-002-A Aircraft Grounding (Earthing) for the Maintenance Operatio
ns
Ref. 20-24-11-100-001-A Cleaning and Protection of the Cables
Ref. 20-24-12-200-001-A Check of the Control Cables
Ref. 20-24-12-200-003-A Inspection of the Pulleys
Ref. 21-26-00-710-001-A Operational Check of the Avionics Equipment Ventilation-Sy
stem via MCDU
Ref. 21-26-00-710-001-A01 Operational Check of the Avionics Equipment Ventilation (wi
thout the CFDS)
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
REFERENCE DESIGNATION
Ref. 24-38-51-400-001-A Installation of the Battery
Ref. 24-41-00-861-002-A Energize the Aircraft Electrical Circuits from the External Po
wer
Ref. 24-41-00-861-002-A01 Energize the Aircraft Electrical Circuits from the APU
Ref. 24-41-00-861-002-A02 Energize the Aircraft Electrical Circuits from Engine 1(2)
Ref. 24-41-00-862-002-A De-energize the Aircraft Electrical Circuits Supplied from th
e External Power
Ref. 24-41-00-862-002-A01 De-energize the Aircraft Electrical Circuits Supplied from th
e APU
Ref. 24-41-00-862-002-A02 De-energize the Aircraft Electrical Circuits Supplied from th
e Engine 1(2)
Ref. 25-65-51-920-001-A Discard and Replace Megaphone Batteries
Ref. 27-14-00-710-001-A Operational Test of the Aileron and Hydraulic Actuation
Ref. 27-24-00-710-001-A Operational Test of the Rudder Hydraulic Actuation
Ref. 27-34-00-710-001-A Operational Test of the Elevator and Hydraulic Actuation
Ref. 27-44-00-710-002-A Operational Test of the Trimmable Horizontal Stabilizer Actu
ator with the Individual Hydraulic Systems
Ref. 27-50-00-866-008-A Extension of the Flaps on the Ground
Ref. 27-50-00-866-008-A01 Extension of the Flaps/Slats on the Ground
Ref. 27-50-00-866-009-A Retraction of the Flaps on the Ground
Ref. 27-50-00-866-009-A01 Retraction of the Flaps/Slats on the Ground
Ref. 27-54-00-710-001-A Operational Test of the Flap System
Ref. 27-64-00-710-001-A Operational Test of the Spoiler Hydraulic Actuation
Ref. 27-80-00-866-004-A Extending the Slats on the Ground
Ref. 27-80-00-866-005-A Retracting the Slats on the Ground
Ref. 27-84-00-710-001-A Operational Test of the Slat System
Ref. 28-11-00-600-010-A Biocidal Preventative Treatment for Aircraft in Long-Term St
orage - With Fuel Mixed with Biobor Biocide
Ref. 28-11-00-600-010-A02 Biocidal Preventative Treatment for Aircraft in Long-Term St
orage - Using Biobor Biocide With a Metered Injection Rig
Ref. 28-23-00-720-001-A Operational Test of Crossfeed Valve Using Individual Motors
and Check Fuel Flow in "Open" and Fuel Shut Off in "Close
d" Positions
Ref. 28-24-00-710-002-A Operational Test of the ENG 1(2) LP Fuel Valve
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
REFERENCE DESIGNATION
Ref. 28-29-00-710-001-A Operational Test of the APU Low Pressure Fuel Valve using e
ach individual Motor in turn
Ref. 29-10-00-200-001-A Check Fluid Level on Reservoir Indicators
Ref. 29-10-00-863-003-A Pressurize the Blue Hydraulic System with a Hydraulic Grou
nd Power-Cart
Ref. 29-10-00-863-003-A01 Pressurize the Blue Hydraulic System with the Blue Electric
Pump
Ref. 29-10-00-864-003-A Depressurize the Blue Hydraulic System
Ref. 29-23-00-863-001-A Pressurize the Green Hydraulic System from the Yellow Hyd
raulic System through the PTU with the Electric Pump
Ref. 29-23-00-864-001-A Depressurize the Green and Yellow Hydraulic Systems after
Operation of the PTU
Ref. 29-24-00-863-001-A Pressurize the Yellow Hydraulic System with the Electric Pu
mp
Ref. 29-24-00-864-001-A Depressurize the Yellow Hydraulic System
Ref. 30-11-00-710-001-A Operational Test of the Wing Ice-Protection System
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
REFERENCE DESIGNATION
Ref. 35-11-41-400-001-A Installation of the Crew Oxygen-Storage Cylinder
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
** ON A/C FSN ALL
3. Job Set-up
SUBTASK 10-12-00-941-059-A
A. General Information
(1) During the storage period, you must do specific ground checks.
The steps you must do for the periodic ground check procedure are given in a table. Y
ou must do each step identified with a cross in the column related to the applicable gr
ound check interval(s).
(2) For the ground checks during the storage period of "Not more than 1 year" and storag
e period of "More than 1 year", refer to the columns that follow:
- At 7-day intervals: column "s7d"
- At 15-day intervals: column "s15d"
- At 1-month intervals: column "s1m"
- At 3-month intervals: column "s3m"
- At 6-month intervals: column "s6m"
- At 1-year intervals: column "s1y"
- At 2-year intervals: column "s2y".
NOTE: You can do a periodic ground check earlier in the specified interval in relation
to your operational conditions.
You can do the different ground checks at the same time.
(3) You must do the applicable steps in the sequence of the table.
SUBTASK 10-12-00-941-060-A
B. Job Set-up
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s
s1 s3 s6 s1 s2
Step 7 1
5d m m y y
d m
(1) Get Access
(a) Put the ACCESS PLATFORM 3M (10 FT)- ADJUSTABLE i X X X X
n position near the aircraft.
(b) Put the ACCESS PLATFORM 15M (49 FT) - ADJUSTABL X
E in position near the aircraft.
(2) Removal of Protection
(a) Remove the Film-- Waterproof Barrier - (Material Ref. X
14HMB1) and the TAPE - ADHESIVE from:
- The avionics ventilation-system inlets and outlets (15HQ
and 22HQ)
- The outflow valve (10HL).
(b) Remove the Film-- Waterproof Barrier - (Material Ref. X
14HMB1) and the TAPE - ADHESIVE from the doors and h
andles.
(c) Remove the Film-- Waterproof Barrier - (Material Ref. X
14HMB1) and the TAPE - ADHESIVE from the landing gear
s.
(3) Aircraft Maintenance Configuration
(a) If the EPSUs disconnection method was chosen at the X X X
entry into storage, connect the EPSUs Ref. AMM TASK 33-
51-38-400-001
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s
s1 s3 s6 s1 s2
Step 7 1
5d m m y y
d m
(e) If the EPSUs disconnection method was chosen at the X
entry into storage, let the aircraft energized for 3 hours.
SUBTASK 10-12-00-865-054-A
C. Make sure that this(these) circuit breaker(s) is(are) closed:
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(1) Open all the access doors to the pressurized area and X
make sure that they operate correctly:
- The passenger/crew doors Ref. AMM TASK 52-10-00
-010-001
- The forward and aft cargo-compartment doors Ref.
AMM TASK 52-30-00-860-001
- The bulk cargo-compartment door Ref. AMM TASK 5
2-30-00-860-006
- The emergency exit hatch Ref. AMM TASK 52-21-11-
000-001.
© AIRBUS S.A.S. ALL RIGHTS RESERVED. CONFIDENTIAL AND PROPRIETARY DOCUMENT.
11/27
1/26/2021 AXM - A318 / A319 / A320 / A321 - AMM - FSN: 301 - 01-Nov-2020 - 10-12-00-553-802-A - Storage Periodic Ground Checks
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(2) Apply Dry lubricant-Anti Seizing PTFE Loaded - (Materi X
al Ref. 03QDB1) on all the seals of the doors.
Make sure that all the doors operate correctly.
(3) Close all the access doors to the pressurized area and X
make sure that they operate correctly:
- The emergency exit hatch Ref. AMM TASK 52-21-11-
400-001
- The bulk cargo-compartment door Ref. AMM TASK 5
2-30-00-860-008
- The forward and aft cargo-compartment doors Ref.
AMM TASK 52-30-00-860-002
- The passenger/crew doors Ref. AMM TASK 52-10-00
-410-001.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(1) Do a General Visual Inspection (GVI) of the airframe f X
rom the ground to make sure that it is in the correct cond
ition.
(a) Make sure that there are no signs of bird nesting in all
areas of the aircraft to which birds have access. If you fin
d bird nests, remove them and clean the aircraft surface a
round the nest.
(b) Do a check for bird excrement. If there is bird excrem
ent, remove it.
(c) Make sure that there are no leaks from:
- The engine drain masts
- The wheels
- The landing gears
- The wings
- The APU
- The horizontal and vertical stabilizers.
(d) Make sure that the protective equipment is correctly i
nstalled.
(e) If a protection is missing on the pitot probe, static pro
be, Total Air Temperature (TAT) sensor or Angle Of Attack
(AOA) sensor:
- Make an entry in the logbook. Install the protection
again.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(3) Do a visual inspection of the aircraft for Foreign Objec X
t Damage (FOD). Also examine for nests, fluid leakage (fu
el and hydraulic fluid), missing parts, blockage and corros
ion of:
(a) The upper and lower surfaces of the wings
(b) The upper surfaces of the ailerons and the spoilers
(c) The lower surfaces of the ailerons
(d) The nacelles, the leading edges of the nacelles and th
e pylons
(e) The flight control surfaces
(f) The external surfaces of the fuselage
(g) The leading edges of the horizontal and vertical stabili
zers
(h) The trailing edges of the horizontal and vertical stabili
zers
(i) The external skin of:
- The passenger/crew doors
- The cargo doors
- The frames around the doors.
(j) The external handles of the passenger/crew doors
(k) The drains:
- In the lower fuselage Ref. AMM TASK 53-59-00-210-001
- On the pylons Ref. AMM TASK 54-50-00-200-002 Ref. A
MM TASK 54-50-00-200-803 Ref. AMM TASK 54-50-00-20
0-805
- On the engines
- At all other locations.
Make sure that all the drain holes of the external structur
e are not clogged.
(l) The toilet areas
(m) All the steel parts and the bare light-alloy areas.
(4) Do a visual inspection of the trailing edge for impacts X
by FOD, fluid leakage (fuel and hydraulic fluid), missing p
arts, blockage and corrosion of:
- The wing rear spar, false rear spar and all the attach
ed equipment
- The upper and lower surfaces of the flaps
- The lower surfaces of the spoilers.
(5) If you find corrosion, remove it Ref. AMM TASK 51-74- X
11-300-001.
SUBTASK 10-12-00-210-093-A
C. Inspection of the Hydraulic System
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(1) Do a check of the reservoir fluid level Ref. AMM TASK X
29-10-00-200-001.
(2) Do a GVI of the hydraulic pipes and unions for corrosi X
on in the areas which are open to the environment (landin
g gear wells, wings and stabilizers).
Where applicable, move the flaps/slats/rudders to get acc
ess.
SUBTASK 10-12-00-710-077-A
D. Landing Gears
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Do a check of the tire and wheel conditions Ref. AMM X
TASK 32-41-00-210-002.
(2) Do a check of the tire pressure Ref. AMM TASK 32-41- X
00-210-003.
If necessary, inflate the tires.
(3) Make sure that the extension of the landing-gear shoc X
k absorbers are correct Ref. AMM TASK 12-14-32-200-001
and Ref. AMM TASK 12-14-32-200-002.
(4) Do a GVI of: X
- The NLG and its doors Ref. AMM TASK 05-27-10-200-00
1,
- The MLG and its doors Ref. AMM TASK 05-27-30-200-00
1 Ref. AMM TASK 05-27-30-200-002 Ref. AMM TASK 05-2
7-30-200-003 Ref. AMM TASK 05-27-30-200-004.
(5) During the GVI, do a check for hydraulic leaks. X
You must make sure that there are no hydraulic leaks (be
cause of a dry seal) on the landing gears and the landing-
gear door actuators before you pressurize the hydraulic sy
stems for the test.
(6) Remove the mooring tool from the NLG. X
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(7) Lift and turn the wheels by hand to make sure that th X
ere are no defects on the bearings:
- For the NLG Ref. AMM TASK 07-12-00-582-001
- For the MLG Ref. AMM TASK 07-12-00-582-002.
(8) Put the aircraft on its wheels. X
(9) Put the aircraft in mooring condition Ref. AMM TASK 1 X
0-20-00-556-001.
(10) Do a check of each wheel-half for corrosion. If you fi X
nd corrosion, clean with Non Aqueous Cleaner-- Petroleum
Based - (Material Ref. 08BBB1).
(11) Do a check of all the painted and unpainted parts for X
corrosion.
(12) Lubricate all the landing gears and the landing gear d X
oors:
- The NLG and the NLG doors Ref. AMM TASK 12-22-32-6
40-002.
- The MLG and the MLG doors Ref. AMM TASK 12-22-32-6
40-001.
(13) Clean all the actuator rods and apply a thin layer of P X
hosphate Ester Hydraulic Fluid-General Power - - (Material
Ref. 02ABA1) on them.
(14) Do a functional test of the normal extension and retr X
action of the landing gear Ref. AMM TASK 32-31-00-720-0
02.
(15) Apply Silicone base Grease-Mechanisms and Seals - - X X
(Material Ref. 03JCA9) on:
- The sliding tube of the shock absorbers
- The actuator rods
- The uplock rollers.
SUBTASK 10-12-00-640-053-A
E. Flight Controls
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Do a check of all the flap tracks for corrosion. X
(2) Do a check of all the slat tracks for corrosion. X
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(3) Do a check of the condition of the flight control cable X
s:
(a) Make sure that the rudder and the Trimmable Horizont
al Stabilizer (THS) cables are lubricated and have no corro
sion in these areas:
- The avionics compartment
- The forward and aft cargo compartments
- Between FR71 and the THS actuator and the rear ru
dder mechanical-control Ref. AMM TASK 20-24-12-2
00-001 and Ref. AMM TASK 20-24-12-200-003.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(11) If the rod-end assembly is installed with the lubricati X
on fittings, lubricate the rudder servo-control-rod eye-end
-bearing Ref. AMM TASK 12-22-27-640-804.
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Do a test of the avionics equipment ventilation-system X
Ref. AMM TASK 21-26-00-710-001.
(2) If the aft cargo-compartment ventilation-system is inst X
alled, do a test of the aft cargo-compartment ventilation-s
ystem Ref. AMM TASK 21-28-00-710-006.
(3) If the forward cargo-compartment ventilation-system i X
s installed, do a test of the forward cargo-compartment ve
ntilation-system Ref. AMM TASK 21-28-00-720-003.
(4) Do a test of the wing ice-protection system Ref. AMM T X
ASK 30-11-00-710-001.
(5) Do a test of the anti-ice system fault-warning Ref. AM X
M TASK 30-21-00-710-001.
(6) Do a test of ENG 1(2) LP-fuel-valve 12QM (13QM) Ref. X
AMM TASK 28-24-00-710-002.
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Do an operational test of the crossfeed valves Ref. AM X
M TASK 28-23-00-720-001.
(2) Do an operational test of the engine LP-fuel shut-off va X
lve Ref. AMM TASK 28-24-00-710-002.
(3) Do an operational test of the APU shut-off valve Ref. A X
MM TASK 28-29-00-710-001.
© AIRBUS S.A.S. ALL RIGHTS RESERVED. CONFIDENTIAL AND PROPRIETARY DOCUMENT.
18/27
1/26/2021 AXM - A318 / A319 / A320 / A321 - AMM - FSN: 301 - 01-Nov-2020 - 10-12-00-553-802-A - Storage Periodic Ground Checks
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(4) Do an operational test of the aileron and its hydraulic s X
ystem Ref. AMM TASK 27-14-00-710-001.
(5) Do an operational test of the elevator and its hydraulic X
system Ref. AMM TASK 27-34-00-710-001.
(6) Do an operational test of the rudder hydraulic actuatio X
n Ref. AMM TASK 27-24-00-710-001.
(7) Do an operational test of the THS actuator with the ind X
ividual hydraulic systems Ref. AMM TASK 27-44-00-710-0
02.
(8) Do an operational test of the flap system Ref. AMM TA X
SK 27-54-00-710-001.
(9) Do an operational test of the spoiler hydraulic system X
Ref. AMM TASK 27-64-00-710-001.
(10) Do an operational test of the slat system Ref. AMM TA X
SK 27-84-00-710-001.
(11) Do an operational test of the landing gear doors Ref. X
AMM TASK 32-31-00-710-002.
SUBTASK 10-12-00-281-057-B
H. Protection of the Fuel System
(1) Protection of the fuel system with fuel treated with biocide
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(1) Do a fuel sampling for microbiological contamination a X
nalysis Ref. AMM TASK 12-32-28-281-003.
If you did the refueling procedure, do the fuel sampling pr
ocedure a minimum of one hour after the end of the refue
ling procedure.
(2) Do a check of the fuel quantity in each tank (wing tan X
ks, center tank and Additional Center Tank (ACT) (if instal
led)).
(a) If you do not find contamination at the start of the sto
rage period or during a ground check:
1_ If premixed fuel with biocide is available:
If necessary, refuel each tank to have a minimum of 10%
of its total capacity (wing tanks, center tank and ACT (if i
nstalled)).
Add fuel that is premixed with Biobor biocide Ref. AMM TA
SK 28-11-00-600-010.
2_ If premixed fuel is not available:
If necessary, refuel each tank to have a minimum of 10%
of its total capacity (wing tanks, center tank and ACT (if i
nstalled)).
Add fuel that is mixed with Biobor biocide with a Metered
Injection Rig Ref. AMM TASK 28-11-00-600-010.
(b) If you find contamination at the start of the storage p
eriod or during a ground check:
1_ If premixed fuel with biocide is available:
If necessary, refuel each tank to have a minimum of 90%
of its total capacity (wing tanks, center tank and ACT (if i
nstalled)).
Add fuel that is premixed with Biobor biocide Ref. AMM TA
SK 28-11-00-600-010.
2_ If premixed fuel is not available:
If necessary, refuel each tank to have a minimum of 90%
of its total capacity (wing tanks, center tank and ACT (if i
nstalled)).
Add fuel that is mixed with Biobor biocide with a Metered
Injection Rig Ref. AMM TASK 28-11-00-600-010.
(3) Drain water: X
- From all the fuel tanks Ref. AMM TASK 12-32-28-28
1-001.
- From the ACT (if installed) Ref. AMM TASK 12-32-28
-281-005.
Do the water drain procedure a minimum of one hou
r after the end of the refueling procedure.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(4) If you did the refueling procedure, make sure that all t X X
he fuel system valves are closed on the ECAM FUEL page
after the refueling procedure.
(2) Protection of the fuel system without fuel treated with biocide
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(1) Do a check of the fuel quantity in each tank (wing tan X
ks, center tank and ACT (if installed)).
If necessary, refuel each tank to have a minimum of 10%
of its total capacity (wing tanks, center tank and ACT (if i
nstalled)) Ref. AMM TASK 12-11-28-650-003 or Ref. AMM
TASK 12-11-28-650-004.
(2) Do a fuel sampling for microbiological contamination a X
nalysis Ref. AMM TASK 12-32-28-281-806.
Do the fuel sampling procedure a minimum of one hour af
ter the end of the refueling procedure.
(3) Drain water: X
- From all the fuel tanks Ref. AMM TASK 12-32-28-28
1-001.
- From the ACT (if installed) Ref. AMM TASK 12-32-28
-281-005.
Do the water drain procedure a minimum of one hou
r after the end of the refueling procedure.
(4) If you did the refueling procedure, make sure that all t X X
he fuel system valves are closed on the ECAM FUEL page
after the refueling procedure.
SUBTASK 10-12-00-614-052-A
J. Oxygen
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Do a check of the pressure of the oxygen cylinders tha
t follow:
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(a) The crew oxygen cylinder(s) Ref. AMM TASK 35-10-00- X
040-001:
- If necessary, replace the crew oxygen cylinder(s) Re
f. AMM TASK 35-11-41-000-001 and Ref. AMM TASK
35-11-41-400-001 or fill the crew oxygen cylinder(s)
Ref. AMM TASK 12-14-35-600-001.
(b) The passenger oxygen cylinders (if installed) Ref. AMM X
TASK 35-21-00-040-001:
- If necessary, fill the passenger oxygen cylinder(s) Re
f. AMM TASK 35-21-00-614-002.
(c) The portable oxygen cylinders (if installed) Ref. AMM T X
ASK 35-32-42-210-002 and Ref. AMM TASK 35-31-42-220
-001.
SUBTASK 10-12-00-680-057-A
K. Air data
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Remove the water from the standby static line Ref. AM X
M TASK 12-24-34-600-001.
SUBTASK 10-12-00-554-051-A
L. Non-revenue Flight
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Do the full return to operation after storage X
(2) Refer to the aircraft maintenance program and make s X
ure that you do all the scheduled maintenance tasks that
are due.
(3) Do a short non-revenue flight within the aircraft stand X
ard envelope.
(4) Do the storage procedure Ref. AMM TASK 10-10-00-55 X
0-801.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) If you did a preservation for a period of not more than X
30 days Ref. AMM TASK 72-00-00-600-006 when you did t
he protection of the engine:
(a) Refer to the engine-preservation renewal procedure Re
f. AMM TASK 72-00-00-600-008.
(b) Do a check of the Integrated Drive Generator (IDG) for
external corrosion Ref. AMM TASK 24-21-00-550-002.
(2) If you did a preservation for a period of more than 30 X
days when you did the protection of the engine:
(a) Examine the desiccant humidity indicator (if used) and
replace the desiccant if necessary.
(3) If you did a preservation procedure for a period of not X
more than 90 days Ref. AMM TASK 72-00-00-600-025 whe
n you did the protection of the engine:
(a) Refer to the engine-preservation renewal procedure Re
f. AMM TASK 72-00-00-600-008.
(b) Do a check of the IDG for external corrosion Ref. AMM
TASK 24-21-00-550-002.
(4) If you did a preservation for a period between 30 and X
365 days Ref. AMM TASK 72-00-00-600-007 when you did
the protection of the engine:
(a) Refer to the engine-preservation renewal procedure Re
f. AMM TASK 72-00-00-600-008.
(b) Do a check of the IDG for external corrosion Ref. AMM
TASK 24-21-00-550-002.
NOTE: ATA 10 gives instructions related to the parking, storage, periodic checks and retur
n to operation of the aircraft. These instructions do not include the APU.
For parking, storage, periodic checks and return to operation of the APU, ATA 10 re
fers to the applicable procedures in the related ATA chapter 49.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s3 s1 s2
Step s7d s 15 d s 1 m s6m
m y y
(1) Do the applicable recommendations X X X X X X X
for regular checks of the APU (in relatio
n to the APU preservation task that you
selected):
- For a GTCP 36-300 APU Ref. AMM TAS
K 49-20-00-600-802
- For an APS 3200 APU Ref. AMM TASK
49-20-00-600-002
- For a 131-9(A) APU Ref. AMM TASK 4
9-20-00-600-803.
SUBTASK 10-12-00-553-075-A
P. Movement of the Aircraft
s
s1 s1 s3 s6 s1 s2
Step 7
5d m m m y y
d
(1) Remove the protection from the brakes and the wheel X
s.
(2) Remove the CHOCK - WHEEL(S) that you installed duri X
ng the storage procedure.
(3) Turn the wheels by 1/4 turn to prevent damage to the X
tires:
(a) Move the aircraft Ref. AMM TASK 09-10-00-584-002 or
(b) Refer to the jacking for wheel change procedures to tu
rn each wheel separately:
- The NLG Ref. AMM TASK 07-12-00-582-001
- The MLG Ref. AMM TASK 07-12-00-582-002.
(4) Put protection on the brakes and the wheels with Film- X
- Waterproof Barrier - (Material Ref. 14HMB1).
(5) If necessary, ground the aircraft Ref. AMM TASK 12-34 X
-24-869-002.
(6) Put the CHOCK - WHEEL(S) in position Ref. AMM TASK X
10-11-00-555-015.
Make sure that the CHOCK - WHEEL(S) do not touch the ti
res. If a tire deflates, the CHOCK - WHEEL(S)will lock.
(7) If necessary, moor the aircraft Ref. AMM TASK 10-20-0 X
0-556-001.
SUBTASK 10-12-00-860-068-A
WARNING: BEFORE YOU PUSH THE DITCHING PUSHBUTTON SWITCH, MAKE SURE THAT
THERE IS NO SUPPLY OF AIR TO THE AIRCRAFT THROUGH THE LOW PRESSU
© AIRBUS S.A.S. ALL RIGHTS RESERVED. CONFIDENTIAL AND PROPRIETARY DOCUMENT.
24/27
1/26/2021 AXM - A318 / A319 / A320 / A321 - AMM - FSN: 301 - 01-Nov-2020 - 10-12-00-553-802-A - Storage Periodic Ground Checks
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(1) Remove the LOCKING TOOL-FLAP SLAT LEVER,INT. PO X
SITION (98D27803000000) from the flap/slat control leve
r.
(2) Retract the flaps Ref. AMM TASK 27-50-00-866-009. X
(3) Retract the slats Ref. AMM TASK 27-80-00-866-005. X
(4) On the CABIN PRESS section of panel 25VU: X X X
- Push the DITCHING pushbutton switch (the ON lege
nd comes on) to close the avionics ventilation skin-v
alves and the outflow valve.
(5) Use the Film-- Waterproof Barrier - (Material Ref. 14H X
MB1) and the TAPE - ADHESIVE to seal:
- The avionics ventilation-system inlets and outlets (15HQ
and 22HQ)
- The outflow valve (10HL).
(6) Use the Film-- Waterproof Barrier - (Material Ref. 14H X
MB1) and the TAPE - ADHESIVE to seal the doors and the
handles.
(7) Depressurize the aircraft hydraulic systems Ref. AMM X
TASK 29-23-00-864-001, Ref. AMM TASK 29-24-00-864-0
01, Ref. AMM TASK 29-10-00-864-003.
(8) Install Film-- Waterproof Barrier - (Material Ref. 14HM X X
B1) with the new TAPE - ADHESIVE to prevent film harde
ning and paint removal.
(9) Put protection at the bottom of the landing gears with X
Film-- Waterproof Barrier - (Material Ref. 14HMB1).
(10) If necessary, moor the aircraft Ref. AMM TASK 10-20 X
-00-556-001.
(11) Remove all the batteries of: X
- The megaphones (if installed) Ref. AMM TASK 25-65-51-
920-001
- The flashlights.
(12) De-energize the aircraft electrical circuits supplied fr X X X
om the external power Ref. AMM TASK 24-41-00-862-002
.
(13) Disconnect and remove batteries 2PB1 and 2PB2 Ref. X X X
AMM TASK 24-38-51-000-001.
REVISION REVISION
CUSTOMIZATION AIRCRAFT TYPES DOCTYPES TITLE
DATE NUMBER
A318 A319 A321 10-12-00-553-802-A - Storage Periodic
AXM AMM 01-Nov-2020 66
A320 Ground Checks
TAIL NUMBER - MSN - FSN: VT-IXR - 03758 - 301
Print date: 2021-01-26 06:44:26
s s s s
s1 s1 s3
Step 7 6 1 2
5d m m
d m y y
(14) If the EPSUs disconnection method was chosen at th X X X
e entry into storage, disconnect the EPSUs Ref. AMM TASK
33-51-38-000-001
5. Close-up
SUBTASK 10-12-00-942-068-A
A. Close-up
(1) Make sure that all the external connections (external power supply, etc.) are disconne
cted from the aircraft. This does not include the aircraft grounding (earthing) cable.
(2) Remove the access platform(s).
(3) Remove all the fixtures, tools, test and support equipment used during this procedur
e.
(4) If you find a defect, make an entry in the logbook.