Professional Documents
Culture Documents
PLAN DE TRABAJO
DEL ESTUDIANTE
TRABAJO FINAL DEL CURSO
1. INFORMACIÓN GENERAL
3. PREGUNTAS GUIA
Durante la investigación de estudio, debes obtener las respuestas a las siguientes interrogantes:
Nº PREGUNTAS
1
The Simple Present Tense
2 Modal Verbs
3
Technical Vocabulary.
2
TRABAJO FINAL DEL CURSO
es to the end
1. The Simple Present
Tense
The present simple is a tense
with two main uses. We use
the simple present tense
when an action is happening
right now, or when it occurs
regularly (or incessantly,
which is why it is sometimes
called present indefinite).
Depending on the person, the
simple present tense is formed
using the stem or adding -s or -
es to the end
4
TRABAJO FINAL DEL CURSO
2. Modal Verbs
6
TRABAJO FINAL DEL CURSO
HOJA DE PLANIFICACIÓN
PROCESO DE EJECUCIÓN
SEGURIDAD / MEDIO AMBIENTE /
OPERACIONES / PASOS /SUBPASOS NORMAS -ESTANDARES
Analizar
Inicio
INSTRUCCIONES: debes ser lo más explícito posible. Los gráficos ayudan a transmitir
mejor las ideas. No olvides los aspectos de calidad, medio ambiente y SHI.
7
TRABAJO FINAL DEL CURSO
In reality, these devices are a special type of ohmmeter in which the low-voltage battery, with
which they are normally equipped, is replaced by a high-voltage generator, so that the
resistance measurement is carried out with very high voltages. With low voltages the currents
so low that they would be impossible to measure.
There are 2 reasons why high voltages are used
The magneto-electric generator is two straight permanent magnets, placed parallel to each
other. The generator armature, together with its iron pole pieces, is mounted between two of
the poles of the parallel magnets, and the pole pieces and the moving core of the instrument
are positioned between the other two poles of the magnets. The armature of the generator is
driven by hand, normally, its speed being increased by means of gears.
8
TRABAJO FINAL DEL CURSO
Tellurometer
The measurement will be performed and the value will be noted. Once this value has
been obtained, the voltage probe is approached 1 m from the previous point and
measured again. The previous operation is repeated but this time moving 1 m away
from the previous point and measured again. If the two new values are identical to the
initial one, or the difference is less than or respectively, the measurement will be
considered correct, since we would be in a linear area and will be recorded in the
installer's report as a ground resistance value.
As in the previous case, the measurement will be taken at this point and those
corresponding to the movement of distance and approach of the voltage probe of 1 m.
If by the values obtained we see that we are already in linear zone we will give the
measurement by correct.
Tachometer
It is a device that measures the rotational speed of a shaft, usually the rotational speed of a
motor. In the case of automobiles, the tachometer indicates the number of complete rotations
made by the crankshaft in a period of time; or, the number of times a piston goes up and down
in its cylinder. It is measured in revolutions per minute
Ammeter
An ammeter in general terms, is a simple galvanometer, with a resistance in parallel, called
"shunt resistance". Having a range of shunt resistors, you can have an ammeter with various
ranges or measurement intervals.
9
TRABAJO FINAL DEL CURSO
LISTA DE RECURSOS
1. MÁQUINAS Y EQUIPOS
Celular
3. HERRAMIENTAS E INSTRUMENTOS
Lapiz
Papel
5. MATERIALES E INSUMOS
10