Professional Documents
Culture Documents
Key Features Lightning damages communications sites arrestors are mounted on a low impedance
all over the world every day. Lightning does ground between the antenna and the point
• Industry's best RF Performance
not have to strike the antenna to significantly where the cable enters the building. This is a
• Low throughput energy damage the antenna or the GPS receiver. commonly used configuration since there is
• Multi-strike capability GPS antenna damage is usually due to often a good earth ground nearby to connect
the effects of a lightning strike on a nearby to. The lightning arrestors require no additional
structure, not the result of a direct lightning power or wiring except the ground lead.
strike. Since lightning strikes may induce If the cable between this lightning arrestor and
damaging voltages in the antenna system the GPS receiver is longer than four meters,
when striking nearby objects, attempt to consider placing a second lightning arrestor
locate the antenna at least 15 meters away within four meters of the GPS receiver. The
from lightning rods, towers, or structures that second arrestor reduces any lightning-
attract lightning. Also, locate the GPS antenna induced voltages in the cable to the receiver.
lower than any structures that will attract a
strike. These units use separate RF (DC-Blocked)
and dc paths through the protector. This
Lightning arrestors will protect your systems design results in low throughput voltage
from lightning damage. In-line lightning and energy.
Microsemi makes no warranty, representation, or guarantee regarding the information contained herein or the suitability of its products and services for any particular purpose, nor does
Microsemi assume any liability whatsoever arising out of the application or use of any product or circuit. The products sold hereunder and any other products sold by Microsemi have been
subject to limited testing and should not be used in conjunction with mission-critical equipment or applications. Any performance specifications are believed to be reliable but are not veri-
fied, and Buyer must conduct and complete all performance and other testing of the products, alone and together with, or installed in, any end-products. Buyer shall not rely on any data and
performance specifications or parameters provided by Microsemi. It is the Buyer’s responsibility to independently determine suitability of any products and to test and verify the same. The information
provided by Microsemi hereunder is provided “as is, where is” and with all faults, and the entire risk associated with such information is entirely with the Buyer. Microsemi does not grant, explic-
itly or implicitly, to any party any patent rights, licenses, or any other IP rights, whether with regard to such information itself or anything described by such information. Information provided in
this document is proprietary to Microsemi, and Microsemi reserves the right to make any changes to the information in this document or to any products and services at any time without notice.
1
DATASHEET
Product Includes GPS Lightning arrestor kit w/50 ft. (15 m) 150-710
cable
• Lightning arrestor, 25' or 50' Beldon 9104 cable with TNC
terminations
Microsemi Corporation (Nasdaq: MSCC) offers a comprehensive portfolio of semiconductor and system solutions for communications,
defense & security, aerospace and industrial markets. Products include high-performance and radiation-hardened analog mixed-sig-
nal integrated circuits, FPGAs, SoCs and ASICs; power management products; timing and synchronization devices and precise time so-
lutions, setting the world’s standard for time; voice processing devices; RF solutions; discrete components; security technologies and
scalable anti-tamper products; Ethernet Solutions; Power-over-Ethernet ICs and midspans; as well as custom design capabilities and ser-
vices. Microsemi is headquartered in Aliso Viejo, Calif., and has approximately 3,600 employees globally. Learn more at www.microsemi.com.