Professional Documents
Culture Documents
DESCRIPTION
FEATURES
* FM input with pre-scalar for radio frequency up to 150 MHz QFP44-10 x10-0.8
* AM input for radio frequency up to 30 MHz
* 3 common, 13 segment, 1/3 bias LCD display drivers which
supports 4 digits LCD display
* On chip oscillator for external 32.768kHz crystal
* 10.7 MHz / 70 kHz I.F. frequency offset for FM signal and 455kHz ORDERING INFORMATIOM
I.F. frequency offset for AM signal
* Internal real time clock in 12 hour display mode
* Selectable clock or frequency display
* 1.8V to 3.3V supply voltage
BLOCK DIAGRAM
SEG10
SEG11
SEG12
COM1
COM2
COM3
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
AVDD
VDD
IF
FMIN AMP PRESCALER
FREQ COUNTER
DIV. BY 10
OFFSET CLKFREQ-SEL
AMI
AMP
N
AM/FM_SEL RST
IF70K
AL-SIG
RANGE TIMMING CTL M CLOCK
U AL-OUT
X
TESTCLK
PR SET
MIN SET
AL ON/OFF
TEST
AL DISP
OSCOUT
AVSS
VSS
OSCIN
PAD ASSIGNMENT
MIN-SET
HR-SET
AL-OUT
RANGE
AL-SIG
IF70K
VSS
NC
NC
NC
33 32 31 30 29 28 27 26 25 24 23
NC 34 22 AL-DISP
AM/FM-SEL 35 21 AL-ON/OFF
AVDD 36 20 TEST
AMIN 37 19 TESTCLK
AVSS 38 18 RST
FMIN 39 SC3610 17 VLCD
VDD 40 16 OSCOUT
COM1 41 15 OSCIN
COM2 42 14 SEG12
COM3 43 13 SEG11
SEG0 44 12 NC
1 2 3 4 5 6 7 8 9 10 11
NC
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
CLKFREQ-SEL
MIN-SET
HR-SET
AL-OUT
RANGE
AL-SIG
IF70K
VSS
NC
NC
35 34 33 32 31 30 29 28 27 26
AM/FM-SEL 36 25 AL-DISP
AVDD 37 24 AL-ON/OFF
AMIN 38 23 TEST
AVSS 39 22 TESTCLK
FMIN 40 21 RST
SC3610C
VDD 1 20 VLCD
COM1 2 19 OSCOUT
COM2 3 18 OSCIN
COM3 4 17 SEG12
SEG0 5 16 SEG11
6 7 8 9 10 11 12 13 14 15
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
FUNCTIONAL DESCRIPTION
2. CLOCK FUNCTION:
1) The clock will be advanced in the following flow:
PM 12:00 → PM 11:59 → AM 12:00 → 11:59
2) The [:] sign is the second indicator and will blink at a rate of 2Hz
3) TIME SETTING:
-- Pressing the keys combination of [TIME SET] [HR SET] or [TIME SET] [MIN SET] will enter the time
setting mode.
-- One digit will be incremented after entering the alarm setting mode. Keep pressing the keys
combination for more than 0.5 seconds will make the digit to be advanced at a rate of 2Hz.
4) ALARM TIME SETTING:
-- Pressing the keys combination of [AL DISP] [HR SET] or [AL DISP] [MIN SET] will enter the alarm time
setting mode. The [AL] indicator will turn on and the [:] sign will stop blinking.
-- One digit will be incremented after entering the alarm setting mode. Keep pressing the keys
combination for more than 0.5 seconds will make the digit to be advanced at a rate of 2Hz.
5) ALARM FUNTION:
-- AL OUT output pin will output an alarm frequency of 1024Hz at 0.2 sec on and 0.2 sec off.
-- AL OUT pin can be used to direct drive a piezo buzzer.
-- When alarm is active, AL OUT output can be disabled by pressing the [AL-ON/OFF] key or it will turn
off automatically after 3 minutes lapse.
-- AL-SIG pin is an open drain output (active low). Once alarm is activated, AL-SIG can be disabled by
pressing [AL-ON/OFF] key or it will turn off automatically after one hour time lapse.
-- When [AL DISP] is pressed, alarm setting time will be displayed on the LCD and the [AL] indicator will
be on.
-- The [AL-ON/OFF] pin will toggle the [ ] indicator to turn on of off the alarm function. When the
indicator is on, alarm function is on.
6) 32.768kHz crystal is used for the reference frequency.
7) After Power-on-reset (RST):
-- [HR SET] and [MIN SET] keys will be disabled.
-- [AL-DISP] KEY,[AL-ON/OFF] KEY AND AL-SIG output will be enabled.
PIN16 PIN1
COL a S1
f gb
4 3 2 e 1 c
DP2 DP1 d
VDD
VLCD 1/3
COM1
VLCD 2/3
VLCD
VDD
VLCD 1/3
COM2
VLCD 2/3
VLCD
VDD
VLCD 1/3
COM3
VLCD 2/3
VLCD
VDD
VLCD 1/3
SEGX.
VLCD 2/3
VLCD
SUGGESTED APPLICATION
500kHz 30MHz
AM Local Oscillator
AM Local Frequency
Oscillator
Clock AMIN
Buffer
Clock
Buffer FMIN
FM Local
Oscillator
MW FM KHz
8 2P 2C 2B e c 2P 1P
LW PM
4 3 2 1 TS
9 2D 2G 2A d
PIN21
PIN1
10 COL 2E 2F
11 -- 3C 3B AM
12 3D 3G 3A MW
LW
13 S1 3E 3F
14 FM 4C 4B stereo
15 4D 4G 4A
SW
16 PM 4E 4F
17 AM
18 AL
19 MW
20 LW
21 SW
SEG10
SEG11
SEG12
COM1
COM2
COM3
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
10nf 10uf
AVDD VDD
VLCD
LCD DRIVER
0.1 F
IF
FMIN PRESCALER
AMP FREQ COUNTER
DIV. BY 10 CLKFREQ-SEL VDD
OFFSET
AMI 4.7k
N AMP
AM/FM-SEL RST 1M
0.1 F
IF70K
AL-SIG
TIMMING CTL M CLOCK
RANGE U AL-OUT
X
AVSS
MIN SET
PR SET
VSS
OSCIN
OSCOUT
AL DISP
AL ON/OFF
TESTCLK
TEST
32.768kHz
20pF 20pF
Page 10 of 13
2007.04.29
9012
10k
470k FM
330k
REV:1.4
0.1 F
MHz
10 F 0.1 F
100k
16 15 14 13 12 11 10 9 8 7 6 5 4
9013 9013
SEG 12
SEG 11
SEG 10
SEG 9
SEG 8
SEG 7
SEG 6
SEG 5
SEG 4
SEG 3
SEG 2
SEG 1
SEG 0
36 VDD
220
2pF 0.1 H 2pF COM3 3
20k 100k
35 FMIN COM2 2
2pF 33 AMIN COM1 1
19 VLCD NC 30 Buzzer
9018
9018 25 NC SC3610D AL-OUT 28
AL-SIG 27
82pF 11 IF Limiter
5.4k
V1 6k HR MIN
68pF Mixer 2.2k 2.2k Allpass Alarm
10k
5k Filter
On/Off
12
220pF VP 0.1 F
Alarm Time
5 Set Set
Demodulator
6k
BB910 VCO
V2 SC1088
680pF Loop filter
4
VP V2
10nF AF
-1
14 V2
3V 5.6k
Http: www.silan.com.cn
& AF
0.1 F 16
V3
0.1 F R MUTE
Search S
Tuning
reset 1 2
Audio Out
0.1 F 1.8nF 10k
SC3610
PACKAGE OUTLINE
QFP-44-10x10-0.8 UNIT: mm
10.0±0.2
13.2±0.3
PACKAGE OUTLINE
ATTACHMENT
Revision History