Professional Documents
Culture Documents
DV-5 Deluge Valve With Remote-Resetting Trim 2 To 8 Inch (DN50 To DN200) General Description
DV-5 Deluge Valve With Remote-Resetting Trim 2 To 8 Inch (DN50 To DN200) General Description
www.tyco-fire.com
Contacts
12 lbs.
Thread Thread N/A N/A N/A N/A
(5,4 kg.)
TABLE A
DV-5 DELUGE VALVE WITH REMOTE-RESETTING TRIM
AVAILABLE END CONNECTIONS AND WEIGHTS
• V-Ring
Applies only to 4 Inch/DN100, 6 Inch/ Operation Installation
DN150 and 8 Inch/DN200 The TYCO Remote-Resetting System The DV-5 Deluge Valve with Remote-
Natural rubber per ASTM D2000 includes a differential valve that uses Resetting Trim is to be installed in
water pressure in the Diaphragm accordance with this section. Refer to
• Diaphragm Cover Fasteners Chamber (Figures 3 and 4) to hold the Figure 11 on Page 15 for UL trim and
Galvanized carbon steel Diaphragm closed against the water Figure 17 on Page 21 for VdS trim.
supply pressure.
Design When the DV-5 Valve with Remote- NOTICE
Resetting Trim is set for service, the Proper operation of the DV-5 Deluge
Criteria Diaphragm Chamber is pressurized Valve with Remote-Resetting Trim
through the trim connections from the depends upon trim installed in accor-
The following items must be consid- inlet side of the system’s main control/ dance with the instructions given in
ered and applied accordingly for shut-off valve, for example an O.S.&Y. this technical data sheet. Failure to
TYCO DV-5 Deluge Valve with Remote- gate valve or butterfly valve. follow the appropriate trim diagram
Resetting Trim installations. may prevent the valve from functioning
Opening of the Solenoid Valve in the properly, may void the manufactur-
NOTICE Remote-Resetting Trim releases water er’s warranty, and will void listings and
from the Diaphragm Chamber faster approvals.
The owner is responsible to design into than it can be replenished through
the system a releasing circuit such that the Restriction in the Diaphragm The DV-5 Deluge Valve and associated
a Solenoid Valve is properly configured Chamber Supply Connection provided trim must be maintained at a minimum
to enable remote resetting. in the trim. This release results in a temperature of 40°F (4°C).
The building owner must be informed rapid pressure drop in the Diaphragm Heat tracing of the DV-5 Deluge Valve
of the capabilities and limitations of a Chamber, and the force differential or its associated trim is not permitted.
remote-resetting system as it pertains applied through the Diaphragm that Heat tracing can result in the formation
to the possibility of an inadvertent holds it in the set position is reduced of hardened mineral deposits that
manual closing of the DV-5 Deluge below the valve trip point. are capable of preventing proper
Valve during a fire condition. Therefore, The water supply pressure then forces operation.
personnel responsible for the fire the Diaphragm open, permitting water
protection system must be fully trained Step 1. Install the deluge valve in a
to flow into the system piping, as well readily visible and accessible location.
on system components and required as through the Alarm Port to actuate
actions in the case of an alarm. system alarms. Step 2. Before trim installation, clean
The Control Panel, Detectors, and Pull all nipples, fittings, and devices to
Closing of the Solenoid Valve in ensure they are free of scale and burrs.
Stations are to be installed in accor- the Remote-Resetting Trim permits
dance with their laboratory listings and Use pipe-thread sealant sparingly on
the Diaphragm Chamber to repres- male pipe threads only.
approval. surize. This repressurizing results in
System piping is to be installed so a pressure increase in the Diaphragm Step 3. For UL arrangements, trim
that it is self-draining. TYCO Model Chamber. The resulting force repres- the deluge valve in accordance with
AD-2 Automatic Drain Valves can be surizes the Diaphragm Chamber, Figures 6 to 10. (VdS arrangements are
used to drain low sections of pipe as closing the valve and stopping the flow fully trimmed.)
necessary. For more information, refer of water into the system piping. Step 4. Exercise care to ensure that
to technical data sheet TFP1632. check valves, strainers, and globe
valves are installed with the flow arrows
in the proper direction.
TFP1331
Page 3 of 24
Step 5. Drain tubing to the drip funnel Step 6. Reset the actuation system. • If there are no leaks, the DV-5 Deluge
must be installed with smooth bends Valve with Remote-Resetting Trim
Manual Actuation — Push the
that will not restrict flow. is ready to place in service and the
Manual Control Station operating
Main Control/Shut-Off Valve must
Step 6. If necessary, connect the main lever up. However, do not close the
then be fully opened.
drain and drip funnel drain, ensuring hinged cover at this time.
that a check valve is located at least 12 Step 12. If equipped in trim, open the
Electric Actuation—Reset the elec-
inches (300 mm) below the drip funnel. Alarm Control Valve.
tric detection system (Control Panel)
Step 7. Ensure suitable provision in accordance with the manufac- For VdS Trim only, the Alarm Control
exists for disposal of drain water (as turer’s instructions to close the Valve is recommended to be wire-
in the case of a flow test via the Main Solenoid Valve. sealed in the open position with a No.
Drain Valve). Direct drain water so that 16 twisted wire, the ends of which are
Step 7. Open the Diaphragm Chamber
it cannot cause accidental damage to secured by a lead seal. The wire seal
Supply Control Valve and allow time
property or danger to persons. should be looped through the hole in
for full pressure to build up in the
the handle and tightly twisted around
Step 8. Connect the Diaphragm Diaphragm Chamber.
the pipe nipple at the outlet of the
Chamber Supply Control Valve to the Step 8. Operate (open) the Manual Alarm Control Valve.
inlet side of the Main Control/Shut-Off Control Station to vent trapped air from
Valve to facilitate setting the valve. the Diaphragm Chamber. NOTICE
NOTICE If necessary, first open the hinged After setting a fire protection system,
cover, and then fully pull down on the notify the proper authorities and
The connection to the Diaphragm operating lever. After aerated water advise those responsible for moni-
Chamber Supply Control Valve should ceases to discharge from the Manual toring proprietary and/or central station
be as short as practical and from the Control Station drain tubing, SLOWLY alarms.
same water supply as the system. close the operating lever by pushing it
Step 9. Make conduit and electrical up. Close the hinged cover and insert a
connections in accordance with the new break rod in the small hole through
requirements of the authority having the top of the enclosing box.
jurisdiction and/or the National Step 9. Inspect drain connections
Electrical Code (NFPA 70). from the Manual Control Station and
Solenoid Valve. Before proceeding to
Valve Setting the next step, correct any leaks.
Step 10. Verify the ability of the
Procedure Diaphragm to hold pressure. With
the Diaphragm Chamber pressur-
Perform Steps 1 through 11 when ized, temporarily close the Diaphragm
initially setting the DV-5 Deluge Valve Chamber Supply Control Valve and
with Remote-Resetting Trim for observe the Diaphragm Chamber
service. Refer to the appropriate trim Pressure Gauge for a drop in pressure.
component functional diagram for your
installation: Figure 11 on Page 15 for • If a drop in pressure occurs, correct
UL and Figure 17 on Page 21 for VdS. any leaks. If necessary, replace the
Diaphragm and/or correct any leaks
Step 1. Close the Diaphragm Chamber before proceeding to the next step.
Supply Control Valve.
• If the Diaphragm Chamber Pressure
Step 2. Close the Main Control/ Gauge does not indicate a drop in
Shut-Off Valve. pressure, re-open the Diaphragm
Step 3. Open the Main Drain Valve. Chamber Supply Control Valve and
proceed to the next step.
Step 4. Depress the plunger of the
Automatic Drain Valve to verify that it Step 11. Slowly open the Main Control/
is open and that the deluge valve is Shut-Off Valve. Close the Main Drain
completely drained. Valve as soon as water discharges
from the drain connection.
Step 5. Clean the Strainer in the
Diaphragm Chamber Supply connec- Observe the Automatic Drain Valve for
tion by removing the clean-out plug leaks.
and strainer basket. Flush the Strainer • If there are leaks, determine/correct
by momentarily opening the Diaphragm the cause of the leakage problem.
Chamber Supply Control Valve.
TFP1331
Page 4 of 24
* Minimum clearance
E* D B* C*
F*
A
G
* Minimum clearance
B* C* D E*
F*
A
FIGURE 2
DV-5 WITH REMOTE-RESETTING TRIM NOMINAL INSTALLATION DIMENSIONS
VdS
(Available for European Markets Only)
TFP1331
Page 6 of 24
DRAIN
ALARM CONTROL VALVE
(NORMALLY OPEN) AUTOMATIC
DRAIN VALVE
WATERFLOW DIAPHRAGM SOLENOID
PRESSURE CHAMBER VALVE
ALARM SWITCH PRESSURE (TYPICALLY
STRAINER GAUGE 24 VOLTS DC)
ALARM TEST VALVE
(NORMALLY CLOSED)
RESTRICTION
WATER SUPPLY DV-5 DRAIN
PRESSURE GAUGE DELUGE
MAIN CONTROL/ VALVE LOCAL
SHUT-OFF VALVE DRAIN MANUAL
DIAPHRAGM (NORMALLY CONTROL
CHAMBER SUPPLY OPEN) STATION
CONTROL VALVE
(NORMALLY OPEN)
FIGURE 4
DV-5 WITH REMOTE-RESETTING TRIM
VdS SYSTEM SCHEMATIC
TFP1331
Page 7 of 24
NOTES:
VALVE PARTS REPLACEMENT PARTS
1. NR - Not Replaceable
No. Description Qty. Repair Parts No. Description P/N
2. CH - Common Hardware
1 Valve Body . . . . . . . . . . . 1 NR (a) Diaphragm Kit,
2 Diaphragm . . . . . . . . . . . 1 (a) 3. Valve Bodies of 4, 6 and 8 Inch (DN100, Includes Item 2:
3 Diaphragm Cover. . . . . . . 1 NR DN150 & DN200) valves are equipped 2 Inch (DN50) Valve . . . . . . . 92-477-1-107
4 Flat Washer, Metric: with studs and Valve Covers are secured 3 Inch (DN80) Valve . . . . . . . 92-477-1-109
2 Inch (DN50) Valve & by Hex Nuts and Hex Bolts. 4 Inch (DN100) Valve . . . . . . . 92-477-1-101
3 Inch (DN80) Valve, 6 Inch (DN150) Valve . . . . . . . 92-477-1-103
4. V-Ring is attached to Diaphragm of 4, 6
M16 . . . . . . . . . . . . . . . . . 4 CH 8 Inch (DN200) Valve . . . . . . . 92-477-1-111
4 Inch (DN100) Valve &
and 8 Inch (DN100, DN150 & DN200)
6 Inch (DN150) Valve, valves at factory. If, during internal valve
M16 . . . . . . . . . . . . . . . . . 8 CH inspection, V-Ring is discovered to be
8 Inch (DN200) Valve, detached from Diaphragm, be advised
M20 . . . . . . . . . . . . . . . . . 8 CH that V-Ring is a required valve component
5 Hex Bolt, Metric: and that detachment will not affect normal
2 Inch (DN50) Valve & valve operation or performance. Should STUDS
3 Inch (DN80) Valve, V-Ring become detached, reinstall (NOTE 3)
M16 x 50 mm. . . . . . . . . . 4 CH 2
between Diaphragm and Diaphragm
4 Inch (DN100) Valve, (NOTE 4)
M16 x 50 mm. . . . . . . . . . 6 CH
Cover concentrically as shown.
6 Inch (DN150) Valve, NOTE: Do not apply adhesives, lubricants,
M16 x 55 mm. . . . . . . . . . 6 CH
or other substances to Diaphragm, V-Ring,
8 Inch (DN200) Valve,
M20 x 70 mm. . . . . . . . . . 6 CH or Valve Body.
6 Hex Nut, Metric:
4 Inch (DN100) Valve &
6 Inch (DN150) Valve,
M16 . . . . . . . . . . . . . . . . . 2 CH 4
8 Inch (DN200) Valve, 6
M20 . . . . . . . . . . . . . . . . . 2 CH (NOTE 3)
1
DIAPHRAGM
ORIENTATION
ORIENT TAB
DIAPHRAGM TAB V-RING
PERPENDICULAR (NOTE 4)
5
TO VALVE BODY
CENTERLINE 4 3
FIGURE 5
DV-5 WITH REMOTE-RESETTING TRIM
VALVE ASSEMBLY
Notes:
1. Flange end 1-1/2 & 2 Inch (DN40 & DN50) DV-5 Valves are not offered.
2. Same drilling as for B16.5 (Class 150) and B16.42 (Class 250).
3. Same drilling as for BS 4504 Section 3.2 (PN10) and DIN 2532 (PN10).
4. Same drilling as for BS 4504 Section 3.2 (PN16) and DIN 2532 (PN16).
TABLE B
DV-5 WITH REMOTE-RESETTING TRIM
FLANGE DRILLING SPECIFICATION
TFP1331
Page 8 of 24
6.0
NOMINAL PRESSURE DROP IN POUNDS PER SQUARE INCH (PSI)
0,40
5.0
0,30
50)
4.0 DN (
3.0 0,20
80)
2 IN
DN
DN
2.0
3 IN
(
CH
)
150
4 IN
(DN
0,10
)
200
0,09
CH
(DN
0,08
6 IN
CH
1.0 0,07
8 IN
0.9 0,06
0.8
0.7 0,05
0.6 0,04
0.5
0,03
0.4
0.3 0,02
50 100 200 400 600 1000 2000 3000 4000
FLOW RATE IN GALLONS PER MINUTE (GPM)
Approximate friction loss, based on the Hazen and Williams formula and expressed in equivalent length of pipe with C=120, is as follows:
16 feet of 2 inch Schedule 40 pipe for the 2 inch DV-5 Valve calculated on a typical flow rate of 175 gpm.
20 feet of 3 inch Schedule 40 pipe for the 3 inch DV-5 Valve calculated on a typical flow rate of 350 gpm.
29 feet of 4 inch Schedule 40 pipe for the 4 inch DV-5 Valve calculated on a typical flow rate of 600 gpm.
46 feet of 6 inch Schedule 40 pipe for the 6 inch DV-5 Valve calculated on a typical flow rate of 1500 gpm.
72 feet of 8 inch Schedule 30 pipe for the 6 inch DV-5 Valve calculated on a typical flow rate of 2500 gpm.
Approximate friction loss, based on the Hazen and Williams formula and expressed in equivalent length of pipe with C=120, is as follows:
5 meters of DN50 Schedule 40 pipe for the DN50 DV-5 Valve calculated on a typical flow rate of 662 lpm.
6 meters of DN80 Schedule 40 pipe for the DN80 DV-5 Valve calculated on a typical flow rate of 1325 lpm.
9 meters of DN100 Schedule 40 pipe for the DN100 DV-5 Valve calculated on a typical flow rate of 2271 lpm.
14 meters of DN150 Schedule 40 pipe for the DN150 DV-5 Valve calculated on a typical flow rate of 5678 lpm.
22 meters of DN200 Schedule 30 pipe for the DN200 DV-5 Valve calculated on a typical flow rate of 9464 lpm.
GRAPH A
DV-5 WITH REMOTE-RESETTING TRIM
NOMINAL PRESSURE LOSS VERSUS FLOW
TFP1331
Page 9 of 24
NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa 18 1/2" x 12" Tubing . . . . . . . 1 CH 39 3/4" x Close Nipple . . . . . 1 CH
Water Pressure Gauge . . 2 92-343-1-005 19 1/4" Plug. . . . . . . . . . . . . . 1 CH 40 3/4" x 1-1/2" Nipple. . . . . 8 CH
2 1/4" Gauge Test Valve . . 1 46-005-1-002 20 3/4" Plug. . . . . . . . . . . . . . 1 CH 41 3/4" x 2" Nipple . . . . . . . . 1 CH
3 Model MC-1 Manual 21 1/2" Union . . . . . . . . . . . . 4 CH 42 3/4" x 4" Nipple . . . . . . . . 1 CH
Control Station. . . . . . . . . 1 52-289-2-001 22 3/4" Union . . . . . . . . . . . . 2 CH 43 3/4" x 2-1/2" Nipple. . . . . 1 CH
4 Model AD-1 Automatic 23 1/4" 90° Elbow. . . . . . . . . 1 CH 44 24 VDC Impulse Ordered
Drain Valve . . . . . . . . . . . 1 52-793-2-004 24 1/2" 90° Elbow. . . . . . . . . 5 CH Solenoid Valve . . . . . . . . 1 Separately
5 Priming Supply 25 3/4" 90° Elbow. . . . . . . . . 1 CH 45 1/2" x 24" Tubing . . . . . . . 1 CH
Restriction, 1/8" Orifice . . 1 92-020-1-009 26 1/2" Tee . . . . . . . . . . . . . . 3 CH
6 Item No. Not Used 27 1/2" x 1/4" x 1/2" Tee. . . . 3 CH COMPONENTS INCLUDED ONLY IN
7 1/2" Ball Valve . . . . . . . . . 2 46-050-1-004 28 3/4" Tee . . . . . . . . . . . . . . 2 CH PRE-TRIMMED VALVE ASSEMBLIES:
8 1/2" Swing Check Valve . 1 46-049-1-004 29 3/4" x 1/2" x 3/4" Tee. . . . 2 CH A1 Waterflow Pressure
9 1/2" Y-Strainer . . . . . . . . . 1 52-353-1-005 30 3/4" x 3/4" x 1/2" Tee. . . . 1 CH Alarm Switch, Model
10 3/4" Swing Check Valve . 1 46-049-1-005 31 1/4" x Close Nipple . . . . . 2 CH PS10-2. . . . . . . . . . . . . . . 1 25710
11 3/4" Angle Valve . . . . . . . 2 46-048-1-005 32 1/2" x Close Nipple . . . . . 3 CH A2 Butterfly Valve,
12 Drip Funnel Connector . . 1 92-211-1-005 33 1/2" x 1-1/2" Nipple. . . . .11 CH Power Ball 300,
13 Drip Funnel Bracket . . . . 1 92-211-1-003 34 1/2" x 2" Nipple . . . . . . . . 2 CH 2" (DN50) . . . . . . . . . . . . . 1 51021A
14 Drip Funnel . . . . . . . . . . . 1 92-343-1-007 35 1/2" x 2-1/2" Nipple. . . . . 3 CH A3 Figure 577 Coupling,
15 3/32" Vent Fitting . . . . . . . 1 92-032-1-002 36 1/2" x 5" Nipple . . . . . . . . 1 CH 2" (DN50) . . . . . . . . . . . . . 1 57720ACP
16 1/4" x 18" Tubing . . . . . . . 1 CH 37 1/2" x 7" Nipple . . . . . . . . 1 CH
17 1/2" Tubing Connector . . 2 CH 38 1/2" Plug . . . . . . . . . . . . . 1 CH
45 44
A1 16 (ORDERED
39 11 17
SEPARATELY)
30
27 40 43
15 33
29 (GREEN 24 33
LOCATION 20 TINT) 35
FOR OPTIONAL 26
ELECTRICALLY 35 28 40 33
21 1
SUPERVISED 40 22
N.O. ALARM 41 26
CONTROL 40 25 27
40 4 33
VALVE 22
10 26 12 37
33 40
40 14 3
24 40 38 33
29
34 13
28 8
11 42 9 5 32
7
33 32 18
35 1
NOTES: 32 17 24
24 21
1. All Fittings and Nipples are 21
19 2
galvanized (Standard Order). A3 33 34
2. CH: Common Hardware. 36
3. Route all Tubing to Drip Funnel, 33 33
21 24
Item 14. 31 27 2" (DN50)
4. Items A1-A3 included only in 31 GROOVE x GROOVE A2
pre-trimmed valve assemblies 23 33
DV-5 DELUGE VALVE
as applicable; otherwise SHOWN
ordered separately. 7
FIGURE 6
2 INCH (DN50) DV-5 WITH REMOTE-RESETTING TRIM
UL
TFP1331
Page 10 of 24
NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa 19 1/2" x 12" Tubing . . . . . . . 1 CH 41 24 VDC Impulse Ordered
Water Pressure Gauge . . 2 92-343-1-005 20 1/4" Plug. . . . . . . . . . . . . . 1 CH Solenoid Valve . . . . . . . . 1 Separately
2 1/4" Gauge Test Valve . . 1 46-005-1-002 21 3/4" Plug. . . . . . . . . . . . . . 1 CH 42 1/2" x 7" Nipple . . . . . . . . 1 CH
3 Model MC-1 Manual 22 1/2" Union . . . . . . . . . . . . 4 CH 43 3/4" x Close Nipple . . . . . 3 CH
Control Station. . . . . . . . . 1 52-289-2-001 23 3/4" Union . . . . . . . . . . . . 2 CH 44 3/4" x 1-1/2" Nipple. . . . . 5 CH
4 Model AD-1 Automatic 24 1/4" 90° Elbow. . . . . . . . . 1 CH 45 3/4" x 2" Nipple . . . . . . . . 1 CH
Drain Valve . . . . . . . . . . . 1 52-793-2-004 25 1/2" 90° Elbow. . . . . . . . . 5 CH 46 3/4" x 4-1/2" Nipple. . . . . 1 CH
5 Priming Supply 26 3/4" 90° Elbow. . . . . . . . . 1 CH 47 1-1/4" x 2" Nipple. . . . . . . 1 CH
Restriction, 1/8" Orifice . . 1 92-020-1-009 27 1/2" Tee . . . . . . . . . . . . . . 3 CH 48 1-1/4" x 4" Nipple. . . . . . . 1 CH
6 Item No. Not Used 28 1/2" x 1/4" x 1/2" Tee. . . . 3 CH 49 1/2" x 24" Tubing . . . . . . . 1 CH
7 1/2" Ball Valve . . . . . . . . . 2 46-050-1-004 29 3/4" Tee . . . . . . . . . . . . . . 1 CH
8 1/2" Swing Check Valve . 1 46-049-1-004 30 3/4" x 1/2" x 3/4" Tee. . . . 2 CH COMPONENTS INCLUDED ONLY IN
9 1/2" Y-Strainer . . . . . . . . . 1 52-353-1-005 31 3/4" x 3/4" x 1/2" Tee. . . . 1 CH PRE-TRIMMED VALVE ASSEMBLIES:
10 3/4" Swing Check Valve . 1 46-049-1-005 32 1-1/4" x 3/4" x 1-1/4" Tee. 1 CH A1 Waterflow Pressure
11 3/4" Angle Valve . . . . . . . 1 46-048-1-005 33 1/4" x Close Nipple . . . . . 2 CH Alarm Switch, Model
12 1-1/4" Angle Valve . . . . . . 1 46-048-1-007 34 1/2" x Close Nipple . . . . . 3 CH PS10-2. . . . . . . . . . . . . . . 1 25710
13 Drip Funnel Connector . . 1 92-211-1-005 35 1/2" x 1-1/2" Nipple. . . . .12 CH A2 Model BFV-N Butterfly
14 Drip Funnel Bracket . . . . 1 92-211-1-003 36 1/2" x 2-1/2" Nipple. . . . . 2 CH Valve, 3" (DN80) . . . . . . . 1 59300F030N
15 Drip Funnel . . . . . . . . . . . 1 92-343-1-007 37 1/2" x 3-1/2" Nipple. . . . . 1 CH A3 Figure 577 Coupling,
16 3/32" Vent Fitting . . . . . . . 1 92-032-1-002 38 1/2" Plug. . . . . . . . . . . . . . 1 CH 3" (DN80) . . . . . . . . . . . . . 1 57730ACP
17 1/4" x 18" Tubing . . . . . . . 1 CH 39 1/2" x 4-1/2" Nipple. . . . . 1 CH
18 1/2" Tubing Connector . . 2 CH 40 1/2" x 5" Nipple . . . . . . . . 1 CH
A1 17 41
43 11
49 (ORDERED
31 SEPARATELY)
28 44 46
16 25
30 (GREEN 35
LOCATION 21 TINT)
36 35 18 35
FOR OPTIONAL 26
ELECTRICALLY 29 27
36
SUPERVISED 44 23 27 22 1
N.O. ALARM 45 4
CONTROL 44 43 27
13
VALVE 44 28
23 38 15 35
35 10
43 42
25 44
14 3
30 35
35 8
32
34
7 47 48
9 5 34
12
40 35 34 19
1
NOTES: 18 25
1. All Fittings and Nipples are 22 25 22
20 2
galvanized (Standard Order). 37
35
2. CH: Common Hardware. 39 A3
3. Route all Tubing to Drip Funnel, 35 35 25
A2 22
Item 15. 33 28
4. Items A1-A3 included only in 33
pre-trimmed valve assemblies 24 3" (DN80) 35
as applicable; otherwise GROOVE x GROOVE
ordered separately. DV-5 DELUGE VALVE 7
SHOWN
FIGURE 7
3 INCH (DN80) DV-5 WITH REMOTE-RESETTING TRIM
UL
TFP1331
Page 11 of 24
NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa 19 1/2" x 24" Tubing . . . . . . . 2 CH 41 24 VDC Impulse Ordered
Water Pressure Gauge . . 2 92-343-1-005 20 1/4" Plug. . . . . . . . . . . . . . 1 CH Solenoid Valve . . . . . . . . 1 Separately
2 1/4" Gauge Test Valve . . 1 46-005-1-002 21 3/4" Plug. . . . . . . . . . . . . . 1 CH 42 3/4" x 1-1/2" Nipple. . . . . 1 CH
3 Model MC-1 Manual 22 1/2" Union . . . . . . . . . . . . 4 CH 43 3/4" x 2" Nipple . . . . . . . . 1 CH
Control Station. . . . . . . . . 1 52-289-2-001 23 1" Union. . . . . . . . . . . . . . 2 CH 44 3/4" x 2-1/2" Nipple. . . . . 1 CH
4 Model AD-1 Automatic 24 1/4" 90° Elbow. . . . . . . . . 1 CH 45 1" x Close Nipple . . . . . . . 5 CH
Drain Valve . . . . . . . . . . . 1 52-793-2-004 25 1/2" 90° Elbow. . . . . . . . . 5 CH 46 1" x 3" Nipple. . . . . . . . . . 1 CH
5 Priming Supply 26 1" 90° Elbow. . . . . . . . . . . 1 CH 47 1" x 6" Nipple. . . . . . . . . . 1 CH
Restriction, 1/8" Orifice . . 1 92-020-1-009 27 1/2" Tee . . . . . . . . . . . . . . 3 CH 48 2" x 3" Nipple. . . . . . . . . . 1 CH
6 Item No. Not Used 28 1/2" x 1/4" x 1/2" Tee. . . . 3 CH 49 2" x 5" Nipple. . . . . . . . . . 1 CH
7 1/2" Ball Valve . . . . . . . . . 2 46-050-1-004 29 3/4" x 1/2" x 3/4" Tee. . . . 2 CH
8 1/2" Swing Check Valve . 1 46-049-1-004 30 1" x 1" x 1/2" Tee. . . . . . . 1 CH COMPONENTS INCLUDED ONLY IN
9 1/2" Y-Strainer . . . . . . . . . 1 52-353-1-005 31 1" x 3/4" x 1" Tee. . . . . . . 1 CH PRE-TRIMMED VALVE ASSEMBLIES:
10 3/4" Swing Check Valve . 1 46-049-1-005 32 2" x 1" x 2" Tee . . . . . . . . 1 CH A1 Waterflow Pressure
11 1" Angle Valve . . . . . . . . . 1 46-048-1-006 33 1/4" x Close Nipple . . . . . 2 CH Alarm Switch, Model
12 2" Angle Valve . . . . . . . . . 1 46-048-1-009 34 1/2" x Close Nipple . . . . . 3 CH PS10-2. . . . . . . . . . . . . . . 1 25710
13 Drip Funnel Connector . . 1 92-211-1-005 35 1/2" x 1-1/2" Nipple. . . . .10 CH A2 Model BFV-N Butterfly
14 Drip Funnel Bracket . . . . 1 92-211-1-003 36 1/2" x 2-1/2" Nipple. . . . . 3 CH Valve, 4" (DN100) . . . . . . 1 59300F040N
15 Drip Funnel . . . . . . . . . . . 1 92-343-1-007 37 1/2" x 3" Nipple . . . . . . . . 1 CH A3 Figure 577 Coupling,
16 3/32" Vent Fitting . . . . . . . 1 92-032-1-002 38 1/2" x 5" Nipple . . . . . . . . 2 CH 4" (DN100) . . . . . . . . . . . . 1 57740ACP
17 1/4" x 24" Tubing . . . . . . . 1 CH 39 1/2" Plug. . . . . . . . . . . . . . 1 CH
18 1/2" Tubing Connector . . 2 CH 40 1/2" x 7" Nipple . . . . . . . . 2 CH
45 11 41
17
19 (ORDERED
A1 30 SEPARATELY)
45 47
28 25
29 35
16
LOCATION 21 (GREEN 36 18 35
37
FOR OPTIONAL TINT) 26 27
ELECTRICALLY 36 45
SUPERVISED 42 22 1
23 23 27 4
N.O. ALARM 43 27
CONTROL 45 13
31 39 35 28
VALVE 15
10 45 40
35
25 44 3
46 14
29 35
8
36
34
7 32 34
9 5
48 49
25 34 19
12
18 25
1 22
40
NOTES: 35
22 35
1. All Fittings and Nipples are 20 2 38
A3
galvanized (Standard Order).
38
2. CH: Common Hardware. 22 25
35 A2
3. Route all Tubing to Drip Funnel, 35
Item 15. 33 28
35
4. Items A1-A3 included only in 33
24
pre-trimmed valve assemblies 4" (DN100) 7
as applicable; otherwise GROOVE x GROOVE
ordered separately. DV-5 DELUGE VALVE
SHOWN
FIGURE 8
4 INCH (DN100) DV-5 WITH REMOTE-RESETTING TRIM
UL
TFP1331
Page 12 of 24
NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa 19 1/2" x 24" Tubing . . . . . . . 2 CH 41 1/2" x 7" Nipple . . . . . . . . 2 CH
Water Pressure Gauge . . 2 92-343-1-005 20 1/4" Plug. . . . . . . . . . . . . . 1 CH 42 24 VDC Impulse Ordered
2 1/4" Gauge Test Valve . . 1 46-005-1-002 21 3/4" Plug. . . . . . . . . . . . . . 1 CH Solenoid Valve . . . . . . . . 1 Separately
3 Model MC-1 Manual 22 1/2" Union . . . . . . . . . . . . 4 CH 43 3/4" x 1-1/2" Nipple. . . . . 1 CH
Control Station. . . . . . . . . 1 52-289-2-001 23 1" Union. . . . . . . . . . . . . . 2 CH 44 3/4" x 2" Nipple . . . . . . . . 1 CH
4 Model AD-1 Automatic 24 1/4" 90° Elbow. . . . . . . . . 1 CH 45 3/4" x 3-1/2" Nipple. . . . . 1 CH
Drain Valve . . . . . . . . . . . 1 52-793-2-004 25 1/2" 90° Elbow. . . . . . . . . 5 CH 46 1" x Close Nipple . . . . . . . 5 CH
5 Priming Supply 26 1" 90° Elbow. . . . . . . . . . . 1 CH 47 1" x 3" Nipple. . . . . . . . . . 1 CH
Restriction, 3/16" Orifice . 1 92-210-1-011 27 1/2" Tee . . . . . . . . . . . . . . 3 CH 48 1" x 9" Nipple. . . . . . . . . . 1 CH
6 Item No. Not Used 28 1/2" x 1/4" x 1/2" Tee. . . . 3 CH 49 2" x 3" Nipple. . . . . . . . . . 1 CH
7 1/2" Ball Valve . . . . . . . . . 2 46-050-1-004 29 3/4" x 1/2" x 3/4" Tee. . . . 2 CH 50 2" x 5" Nipple. . . . . . . . . . 1 CH
8 1/2" Swing Check Valve . 1 46-049-1-004 30 1" x 1" x 1/2" Tee. . . . . . . 1 CH
9 1/2" Y-Strainer . . . . . . . . . 1 52-353-1-005 31 1" x 3/4" x 1" Tee. . . . . . . 1 CH COMPONENTS INCLUDED ONLY IN
10 3/4" Swing Check Valve . 1 46-049-1-005 32 2" x 1" x 2" Tee . . . . . . . . 1 CH PRE-TRIMMED VALVE ASSEMBLIES:
11 1" Angle Valve . . . . . . . . . 1 46-048-1-006 33 1/4" x Close Nipple . . . . . 2 CH A1 Waterflow Pressure
12 2" Angle Valve . . . . . . . . . 1 46-048-1-009 34 1/2" x Close Nipple . . . . . 3 CH Alarm Switch, Model
13 Drip Funnel Connector . . 1 92-211-1-005 35 1/2" x 1-1/2" Nipple. . . . .10 CH PS10-2. . . . . . . . . . . . . . . 1 25710
14 Drip Funnel Bracket . . . . 1 92-211-1-003 36 1/2" x 2-1/2" Nipple. . . . . 2 CH A2 Model BFV-N Butterfly
15 Drip Funnel . . . . . . . . . . . 1 92-343-1-007 37 1/2" x 5-1/2" Nipple. . . . . 1 CH Valve, 6" (DN150) . . . . . . 1 59300F060N
16 3/32" Vent Fitting . . . . . . . 1 92-032-1-002 38 1/2" x 3" Nipple . . . . . . . . 1 CH A3 Figure 577 Coupling,
17 1/4" x 24" Tubing . . . . . . . 1 CH 39 1/2" x 5" Nipple . . . . . . . . 2 CH 6" (DN150) . . . . . . . . . . . . 1 57760ACP
18 1/2" Tubing Connector . . 2 CH 40 1/2" Plug. . . . . . . . . . . . . . 1 CH
17 46 11 42
A1 30 19 (ORDERED
SEPARATELY)
46 48
28 25
29 35
16 36
LOCATION 21 (GREEN 38 18 35
FOR OPTIONAL TINT) 27
ELECTRICALLY 36 43 26 22 1
SUPERVISED 27
N.O. ALARM 44 23 46 4
27
CONTROL 31 23 13
35 28
VALVE 46 40
10 41
35
45 47
25 3
29 15
35
46 8
14 34
37 34
9 5
32 34
7 25 19
49 50
18 25
12 22
1 35
41 39
22
20 2 35
22 25
NOTES: 39 35
1. All Fittings and Nipples are 35
A3 35
galvanized (Standard Order). 33 28
2. CH: Common Hardware.
33 7
3. Route all Tubing to Drip Funnel, 24 A2
Item 15. 6" (DN150)
4. Items A1-A3 included only in GROOVE x GROOVE
pre-trimmed valve assemblies DV-5 DELUGE VALVE
as applicable; otherwise SHOWN
ordered separately.
FIGURE 9
6 INCH (DN150) DV-5 WITH REMOTE-RESETTING TRIM
UL
TFP1331
Page 13 of 24
NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N NO. DESCRIPTION QTY. P/N
1 300 psi/ 2000 kPa 19 1/2" x 24" Tubing . . . . . . . 2 CH 41 1/2" x 7" Nipple . . . . . . . . 2 CH
Water Pressure Gauge . . 2 92-343-1-005 20 1/4" Plug. . . . . . . . . . . . . . 1 CH 42 24 VDC Impulse Ordered
2 1/4" Gauge Test Valve . . 1 46-005-1-002 21 3/4" Plug. . . . . . . . . . . . . . 1 CH Solenoid Valve . . . . . . . . 1 Separately
3 Model MC-1 Manual 22 1/2" Union . . . . . . . . . . . . 4 CH 43 3/4" x 1-1/2" Nipple. . . . . 1 CH
Control Station. . . . . . . . . 1 52-289-2-001 23 1" Union. . . . . . . . . . . . . . 2 CH 44 3/4" x 2" Nipple . . . . . . . . 1 CH
4 Model AD-1 Automatic 24 1/4" 90° Elbow. . . . . . . . . 1 CH 45 3/4" x 4-1/2" Nipple. . . . . 1 CH
Drain Valve . . . . . . . . . . . 1 52-793-2-004 25 1/2" 90° Elbow. . . . . . . . . 5 CH 46 1" x Close Nipple . . . . . . . 5 CH
5 Priming Supply 26 1" 90° Elbow. . . . . . . . . . . 1 CH 47 1" x 3" Nipple. . . . . . . . . . 1 CH
Restriction, 3/16" Orifice . 1 92-210-1-011 27 1/2" Tee . . . . . . . . . . . . . . 3 CH 48 1" x 12" Nipple. . . . . . . . . 1 CH
6 Item No. Not Used 28 1/2" x 1/4" x 1/2" Tee. . . . 3 CH 49 2" x 3" Nipple. . . . . . . . . . 1 CH
7 1/2" Ball Valve . . . . . . . . . 2 46-050-1-004 29 3/4" x 1/2" x 3/4" Tee. . . . 2 CH 50 2" x 5" Nipple. . . . . . . . . . 1 CH
8 1/2" Swing Check Valve . 1 46-049-1-004 30 1" x 1" x 1/2" Tee. . . . . . . 1 CH
9 1/2" Y-Strainer . . . . . . . . . 1 52-353-1-005 31 1" x 3/4" x 1" Tee. . . . . . . 1 CH COMPONENTS INCLUDED ONLY IN
10 3/4" Swing Check Valve . 1 46-049-1-005 32 2" x 1" x 2" Tee . . . . . . . . 1 CH PRE-TRIMMED VALVE ASSEMBLIES:
11 1" Angle Valve . . . . . . . . . 1 46-048-1-006 33 1/4" x Close Nipple . . . . . 2 CH A1 Waterflow Pressure
12 2" Angle Valve . . . . . . . . . 1 46-048-1-009 34 1/2" x Close Nipple . . . . . 3 CH Alarm Switch, Model
13 Drip Funnel Connector . . 1 92-211-1-005 35 1/2" x 1-1/2" Nipple. . . . .10 CH PS10-2. . . . . . . . . . . . . . . 1 25710
14 Drip Funnel Bracket . . . . 1 92-211-1-003 36 1/2" x 2-1/2" Nipple. . . . . 2 CH A2 Model BFV-N Butterfly
15 Drip Funnel . . . . . . . . . . . 1 92-343-1-007 37 1/2" x 8-1/2" Nipple. . . . . 1 CH Valve, 8" (DN200) . . . . . . 1 59300F080N
16 3/32" Vent Fitting . . . . . . . 1 92-032-1-002 38 1/2" x 3" Nipple . . . . . . . . 1 CH A3 Figure 577 Coupling,
17 1/4" x 24" Tubing . . . . . . . 1 CH 39 1/2" x 5" Nipple . . . . . . . . 2 CH 8" (DN200) . . . . . . . . . . . . 1 57780ACP
18 1/2" Tubing Connector . . 2 CH 40 1/2" Plug. . . . . . . . . . . . . . 1 CH
46 11
A1 17 30
46 42
25 19 (ORDERED
28 SEPARATELY)
29 36
16
LOCATION 21 (GREEN 38 35
FOR OPTIONAL TINT) 48
18 35
ELECTRICALLY 36 43 27
SUPERVISED 4 27
23 26
N.O. ALARM 44 13
46 22 1
CONTROL 31
VALVE 46 27
10 40
47 35 28
35 45 15
29 41
25
46 35 3
14
23 19
37 22
8 34
32
34
7 49 50
9 5 18 25
12
35 34
39
41 1
22 35 25 25
20 2
35
39 22
35
33 28 35
NOTES: A3
1. All Fittings and Nipples are 33
24
galvanized (Standard Order). 7
A2
2. CH: Common Hardware. 8" (DN200)
3. Route all Tubing to Drip Funnel, GROOVE x GROOVE
Item 15. DV-5 DELUGE VALVE
4. Items A1-A3 included only in SHOWN
pre-trimmed valve assemblies
as applicable; otherwise
ordered separately.
FIGURE 10
8 INCH (DN200) DV-5 WITH REMOTE-RESETTING TRIM
UL
TFP1331
Page 14 of 24
VENT FITTING
(GREEN TINT) SYSTEM
WATERFLOW NOTES:
PRESSURE ALARM DRAIN VALVE
(NORMALLY 1. Install subassemblies in alphabetical order.
SWITCH, ORDERED
CLOSED) 2. See Figures 5 thru 10 to identify connection sizes
SEPARATELY
and unassembled components.
K
AUTOMATIC 3. Route all Tubing to Drip Funnel.
WATER DRAIN VALVE
MOTOR ALARM
CONNECTION
DRIP
FUNNEL SOLENOID VALVE,
J ORDERED SEPARATELY
B L (NORMALLY CLOSED)
DRIP DV-5
FUNNEL DRAIN DELUGE
DIAPHRAGM
CONNECTION VALVE
CHAMBER
MAIN A PRESSURE
DRAIN VALVE GAUGE
(NORMALLY
CLOSED) E F
G MANUAL
ALARM MAIN DRAIN CONTROL
TEST VALVE CONNECTION STATION
(NORMALLY
CLOSED) D
SYSTEM H
WATER DIAPHRAGM
SUPPLY WATER SUPPLY CHAMBER SUPPLY
PRESSURE C CONNECTION CONTROL VALVE
GAUGE (NORMALLY
OPEN)
FIGURE 11
DV-5 WITH REMOTE-RESETTING TRIM
UL LISTED
COMPONENT FUNCTIONS AND SEMI-PRESSEMBLED TRIM ARRANGEMENT
TFP1331
Page 15 of 24
40
10
9
39 5 40
13
4
33 10
34
6 14 3
1 21 32 2
29
8 14 27
15 4 37 30
24 16 6
17
37 23
19 6
15 5 17 18
25
38 16
22 8
7 31
40 35 28
2
16 11
10 27
33 26
20 12 16
3 36
6
23
29
11
38
FIGURE 12
2 INCH (DN50) DV-5 WITH REMOTE-RESETTING TRIM
VdS
(Available for European Markets Only)
TFP1331
Page 16 of 24
41
10
9
40 41
5 13
4
34 10
35
6 14 3
1 33 2
22 30
14 31 28
8
15 4 38 25 16 6
17
38 24
20 6
5 17 19
15 26
18
39 23 8
7 32
41 36 29
2
16 11
28
34 10 27
12 16
21
3 37
6
24
30
11
39
FIGURE 13
3 INCH (DN80) DV-5 WITH REMOTE-RESETTING TRIM
VdS
(Available for European Markets Only)
TFP1331
Page 17 of 24
40
11
10 40
39 5 14
4 33
34 10
15 3
6 32
1 30
22 8 25 29
2
9 27
16 4 37 17 6
22 23
37
19 6
16 5 22 18
24
38 21 20 9
7 31
40 35 28 2
17 27 12
33 11
26
21 13 17
3 36
6
23
29
12
38
FIGURE 14
4 INCH (DN100) DV-5 WITH REMOTE-RESETTING TRIM
VdS
(Available for European Markets Only)
TFP1331
Page 18 of 24
41
11
10
40 5 14 41
4
15 34 11
35
6 33
1 31 3
23 8 26
9 30
2
16 4 38
28
18
17 6
38
24
5 18 20 6
16 19
21 9 25
39 22
36 7 32
41 29 2
17 28 12
34 11 27
22 13 17
3 37
6
24
30
12
39
FIGURE 15
6 INCH (DN150) DV-5 WITH REMOTE-RESETTING TRIM
VdS
(Available for European Markets Only)
TFP1331
Page 19 of 24
40
10
9 13
39 5
4
20 40
14
6 32 33 10
30 34
15 22 8 25
1 9 3
4 37 29
2
17
27
37
16 6
23
5 17
19 6
20 9 18
15 24
35
38 21 7 31
28 2
40 16 27 11
26
33 10 12 16
36
21
3 23
6
29 38
11
FIGURE 16
8 INCH (DN200) DV-5 WITH REMOTE-RESETTING TRIM
VdS
(Available for European Markets Only)
TFP1331
Page 20 of 24
B
N H
Item Description
A DV-5 Valve
B Waterflow Switch
C
C System Drain Valve
D Automatic Drain Valve
E Alarm Test Valve
2 A F Alarm Control Valve
G Water Supply Gauge
H Diaphragm Gauge
F J System Gauge
E 3 K Manual Control Station
K
L Diaphragm Supply Valve
D M Diaphragm Supply Strainer
G N Solenoid Valve
1 Diaphragm Supply Connection
2 Water Motor Alarm Connection
M 3 Main Drain Connection
L
1
FIGURE 17
DV-5 WITH REMOTE-RESETTING TRIM
VdS COMPONENT FUNCTIONS
(Available for European Markets Only)
P/N XX X XX XX X XX
DELUGE VALVE
SWITCH
80 Flange x Flange*, PN 16
TRIM 2 PS10-2
81 Flange x Flange**, ANSI
80 UL
82 Flange x Groove*, PN 16 SIZE
TABLE C
DV-5 WITH REMOTE-RESETTING TRIM
FULLY ASSEMBLED PART NUMBERS FOR UL TRIM
P/N XX X XX XX X XX
DELUGE VALVE
SWITCH
80 Flange x Flange*, PN 16
TRIM 1 PS10-1
81 Flange x Flange**, ANSI
89 VdS
82 Flange x Groove*, PN 16 SIZE
TABLE D
DV-5 WITH REMOTE-RESETTING TRIM
FULLY ASSEMBLED PART NUMBERS FOR VdS TRIM
(Available for European Markets Only)
TFP1331
Page 24 of 24