Professional Documents
Culture Documents
A. 260°C.
B. 135°C.
C. 200°C.
17. Before effecting a crimp, the bare ends of a cable should be.
A. tightly twisted.
B. twisted lightly in the direction of the lay.
C. straightened out.
18. A hole is placed in the lowest point of electrical cable conduit.
A. to allow for pull-through of the cables.
B. to secure the conduit to a piece of aircraft structure.
C. to allow for drainage of moisture.
19. The minimum distance between electrical cable splices is.
A. 3 feet.
B. 12 inches.
C. 500 mm
20. When splicing a cable with a soldered joint, the operation is finished when.
A. the solder has melted.
B. the solder sleeve disappears.
C. the solder and insulation have formed.
21. When manufacturing an electrical connector the unused holes are.
A. filled with connectors.
B. filled with connectors and blanked.
C. covered with blanks.
22. Why are copper wires used in electrical systems?.
A. They have high permeability.
B. They do not give off a magnetic field.
C. They have a low resistance to current.
23. A white/blue insertion-extraction tool would be used on a cable of what size?.
A. 10.
B. 22.
C. 16.
24. What gauge of pin would a blue plastic insert / extract tool be used on?.
A. 12 - 10.
B. 16 - 14.
C. 22 - 18.
25. What gauge of pin would a yellow plastic insert/extract tool be used on?.
A. 16 - 14.
B. 12 - 10.
C. 22 - 18.