Professional Documents
Culture Documents
Lab Report: 20 %
Lab Task and Performance: 20%
Lab Evaluation: 20 %
Lab Project: 10 %
Viva/Oral Questions: 30%
1
University of Engineering and Technology, Peshawar
Faculty of Mechanical, Chemical, Industrial, Mechatronics & Energy Engineering
Department of Mechanical Engineering
COURSE LEARNING
RECOMMENDED BOOKS OUTCOMES (CLOs)
CLO Statement
1. Microprocessor Mapping by Goanikar,
Architecture, Programming and Applications Mapping 2nd
with
with
edition ISBN-10: 0675206758, Merril Publishing Co. ,March 1989 PLO Bloom’s
Taxonomy
CLO-1 Adopt ethical principles and necessary
2. The 8051 Microcontroller and Embedded Systems withPLO-8 Software by Muhammad
A3
guidelines for students' health and safety while
Ali Mazidi, 2nd edition, ISBN-10: 8178085747, Pearson Education, 2000
working in the laboratory
CLO-2 Analyze
3. Ronald experimental
J. Tocci, data andGregory
Neal S. Widmer, document PLO-9
L. Moss, Digital C3 and
Systems Principles
findings of the experiment through writing
Applications, 12th edition, ISBN: 0134220137, Pearson Publishing, 2011
technical report
CLO-3 PLO-1 P3
COURSE To recognize /and
CONTENTS understand
LIST the function of
OF EXPERIMENTS
1. Introduction to Mechatronics
mechatronics Lab: Overview
system components and of lab equipment (multimeter, bread board,
Veroprogramming language
board, Electronics for etc.)
Symbols micro-controller
CLO-4 To be able to control mechanical PLO-3 P7
2. Introduction to electronics (Active
components/mechanism usingandmicro-controller
Passive)
3. Understating function and uses of transformer, voltage regulators, diode bridge
4. Controlling 220v power using Relay, its function and uses
5. Introduction to microcontroller development board and its use
6. Programming for microcontroller, loading program into microcontroller
7. Microcontroller pin-configuration and development a basic reset circuit
8. Interfacing LEDs to microcontroller and displaying Binary Patterns (Blinking LEDS)
9. DC motor interfacing with Microcontroller (Speed and Direction control)
10. Stepper motor interfacing with Microcontroller
11. Interfacing ADC and DAC with Microcontroller
12. Interfacing an 16 x 2 LCD to the Microcontroller
COURSE OBJECTIVES
The objectives of the course are to improve students’ cognitive and psycho motor skills. To
Understand the basic concepts of Mechatronics and apply these fundamental concepts to control a
mechanical part/system. At the end of this course the students will be able to use different
electronics components to control any machine part.
2
University of Engineering and Technology, Peshawar
Faculty of Mechanical, Chemical, Industrial, Mechatronics & Energy Engineering
Department of Mechanical Engineering
3
University of Engineering and Technology, Peshawar
Faculty of Mechanical, Chemical, Industrial, Mechatronics & Energy Engineering
Department of Mechanical Engineering
4
University of Engineering and Technology, Peshawar
Faculty of Mechanical, Chemical, Industrial, Mechatronics & Energy Engineering
Department of Mechanical Engineering
5
University of Engineering and Technology, Peshawar
Faculty of Mechanical, Chemical, Industrial, Mechatronics & Energy Engineering
Department of Mechanical Engineering