Professional Documents
Culture Documents
P0121 Throttle (TPS) signal inconsistent with MAF, IACV, air temp & engine rpm Y B
P0122 Throttle (TPS) circuit low input Y A
P0123 Throttle (TPS) circuit high input Y A
P0125 Water temperature sensor - insufficient for Closed Loop Fuel Control Y B
P1138 Oxygen sensor problem with switching lean, sensor(s) for Bank A Y C
P1158 Oxygen sensor problem with switching lean, sensor(s) for Bank B Y C
P1137 Oxygen sensor problem with switching rich, sensor(s) for Bank A Y C
P1157 Oxygen sensor problem with switching rich, sensor(s) for Bank B Y C
P0181 Fuel temperature sensor fault - reading invalid compared with water temp Y A
P0182 Fuel temperature sensor circuit low range fault Y A
P0183 Fuel temperature sensor circuit high range fault Y A
P1187 Oxygen sensor heater circuit inferred open circuit, upstream sensors Y C
P1188 Oxygen sensor heater circuit high resistance, upstream sensors Y C
P1189 Oxygen sensor heater circuit inferred low resistance, upstream sensors Y C
P1190 Oxygen sensor heater circuit low resistence, upstream sensors Y C
P1193 Oxygen sensor heater circuit inferred open circuit, downstream sensors Y C
P1194 Oxygen sensor heater circuit high resistance, downstream sensors Y C
P1195 Oxygen sensor heater circuit inferred low resistance, downstream sensors Y C
P1196 Oxygen sensor heater circuit low resistence, downstream sensors Y C
MIL Drive
P03xx, P13xx Ignition System or Misfire Y / N Cycle
P0300 Misfire on multiple cylinders (NAS only) Y C
P0301 Misfire on cylinder 1 (NAS only) Y C
P0302 Misfire on cylinder 2 (NAS only) Y C
P0303 Misfire on cylinder 3 (NAS only) Y C
P0304 Misfire on cylinder 4 (NAS only) Y C
P0305 Misfire on cylinder 5 (NAS only) Y C
P0306 Misfire on cylinder 6 (NAS only) Y C
P0307 Misfire on cylinder 7 (NAS only) Y C
P0308 Misfire on cylinder 8 (NAS only) Y C
P1313 Misfire likely to cause damage to catalyst Bank A (NAS only) Y C
P1314 Misfire likely to cause damage to catalyst Bank B (NAS only) Y C
P1315 Persistent misfires (NAS only) Y C
P1316 Misfire causing excess emissions (NAS only) Y C
P1317 ABS - rough road signal line permanently at ground or open circuit Y A
P1318 ABS - rough road signal line permanently at +12V Y A
MIL Drive
P04xx, P14xx Auxiliary Emissions Control Y / N Cycle
P0420 Catalyst efficiency is low, Bank A (NAS only) Y C
P0430 Catalyst efficiency is low, Bank B (NAS only) Y C
MIL Drive
P05xx, P15xx Vehicle Speed, Idle Control and Auxiliary Inputs Y / N Cycle
P0500 Vehicle speed signal out of range Y B
P0506 Low idle speed Y A
P0507 High idle speed Y A
P0508 IACV Stepper motor circuit open circuit Y *
P0509 IACV Stepper motor circuit short circuit Y *
P1514 Neutral drive switch fault - indicates neutral during high load Y B
P1516 Neutral drive switch fault - indicates neutral during gear change Y B
P1517 Neutral drive switch fault - indicates drive during cranking Y B
P0560 ECM reads low battery voltage at engine speeds where alternator should be operating Y A
P0562 Battery voltage read by ECM too low to be possible N A
P0563 Battery voltage read by ECM too high to be possible N A
MIL Drive
P06xx, P16xx Computer and Auxiliary Outputs Y / N Cycle
P0605 ECM self check fault - Adaption and fault record memory corrupted Y A
P1607 MIL circuit open or short circuit N A
P1621 Communications with the security ECM has not happened within the expected time N A
P1622 3 non-identical or 2 identical wrong security codes received by ECM in sequence N A
MIL Drive
P07xx, P17xx, P18xx Transmission Y / N Cycle
P1701 Transfer box has signalled a fault condition to the ECM (RR only) Y A
P1703 Transfer box link - signal line permanently at +12V or open circuit (RR only) Y A
P1708 Transfer box link - signal line permanently at ground (RR only) Y A
P1775 Gearbox has signalled a fault condition to the ECM (RR only) Y B
P1776 Gearbox ignition retard request duration fault (RR only) Y B
P1777 Gearbox ignition retard request line fault (RR only) Y B