Professional Documents
Culture Documents
com/)
LEARNING (HTTPS://WWW.ELECCIRCUIT.COM/LEARN-ELECTRONICS/)
CIRCUITS (HTTPS://WWW.ELECCIRCUIT.COM/SIMPLE-ELECTRONIC-CIRCUITS/)
PROJECTS (HTTPS://WWW.ELECCIRCUIT.COM/EASY-ELECTRONIC-PROJECTS/)
SUPPLIES (HTTPS://WWW.ELECCIRCUIT.COM/POWER-SUPPLY-CIRCUIT/)
AMPLIFIERS (HTTPS://WWW.ELECCIRCUIT.COM/AMPLIFIER-CIRCUIT/)
BLOG (HTTPS://WWW.ELECCIRCUIT.COM/BLOG/)
ABOUT (HTTPS://WWW.ELECCIRCUIT.COM/ABOUT-US/)
Blog
:: Home (https://www.eleccircuit.com/) » Power supply (https://www.eleccircuit.com/power-supply/) » 12V
SEARCH THIS
12V Dual Power Supply SITE
Amplifiers
This is +/- 12v dual power supply circuit diagram using
(https://www.eleccircuit.com/
7812 and 7912. We use an LM7812 voltage regulator
amplifier/) (113)
IC for +12V and LM7912 for -12V. This circuit is suitable
Preamplifiers
for a preamplifier tone control with OP-AMP circuit. It (https://www.eleccircuit.com/
can deliver an output current not more than 1A. amplifier/preamplifiers/) (15)
Power supply
I will show you, with an interesting concept. When we
(https://www.eleccircuit.com/
build a small preamplifier circuit. It needs to use a power power-supply/) (81)
supply. It requires low supply current is only 100mA. But Variable Supply
It is special that the need for dual voltage in three (https://www.eleccircuit.com/
terminals positive, negative and ground. So, we use a power-supply/variable/) (23)
Sound Generator
(https://www.eleccircuit.com/
sound-generator/) (22)
Oscillator circuits
(https://www.eleccircuit.com/
oscillator-circuits/) (21)
555 Timer
(https://www.eleccircuit.com/
555-timer/) (22)
(https://www.eleccircuit.com/wp- Basic Electronics
content/uploads/2017/03/dual-power-regulator-12v-12v- (https://www.eleccircuit.com/
basic-electronics/) (59)
by-lm7812-lm7912.jpg)
TOP PROJECTS
+/- 12V dual power supply circuit CIRCUITS
If your load use low current not more than 300mA. You
TDA2050 Power Amplifier
may use this circuit. (https://www.eleccircuit.com/
In the circuit, There is an unregulated power supply. tda2050-amplifier-stereo-
35w-75w/)
Which they include S1, F1, T1, D1, D2, C1, C2, C3, and
C4. Since they are two rectifier diodes in half wave 12V to 5V converter
rectifier form. You should use the double filter capacitors, (https://www.eleccircuit.com/
12v-to-5v-converter-step-
C2 and C4. To reduce a ripple voltage.
down-3a-regulator/)
This circuit uses 300mA transformer AC 15V CT 15V. Pre amplifier with Tone
(30V) When it converts to DCV. This voltage rises up to control
about of 42VDC. Each input voltage is 21VDC comes to (https://www.eleccircuit.com/
three-circuits-of-preamp-
7812 and 7912. Both IC-regulator keeps a constant
tone-controls-by-ne5532/)
voltage to the output.
LAST
COMMENTS
Apichet Garaipoom
(https://www.eleccircuit.com/wp- (https://www.eleccircuit.com)
on TDA2030 transistor
content/uploads/2017/03/12v-dual-power-supply.png)
amplifier circuit with PCB
(https://www.eleccircuit.com/
Change the current size of a transformer of 1A
the-otl-amplifier-listen-
secondary coil. comfortably-by-tda2030-
Using Full wave rectifier diodes is better. They have 4 and-tip41tip42/#comment-
332649)
diodes, 1N4007.
So, You can use two filter capacitors. But there is a Apichet Garaipoom
(https://www.eleccircuit.com)
higher current than above.
on TDA2030 transistor
C3, C4, C7 and C4 filter capacitors to clean transient amplifier circuit with PCB
voltage from input. (https://www.eleccircuit.com/
Also, C5 and C6 capacitor filtered the ripple voltage the-otl-amplifier-listen-
comfortably-by-tda2030-
to the output.
and-tip41tip42/#comment-
LED1 shows power on using a limitting current 332648)
resistor (https://www.eleccircuit.com/current-
Apichet Garaipoom
limiting-resistor/). (https://www.eleccircuit.com)
on TDA2030 transistor
Parts you will need amplifier circuit with PCB
(https://www.eleccircuit.com/
IC1: 7812 positive voltage regulator the-otl-amplifier-listen-
comfortably-by-tda2030-
(https://www.eleccircuit.com/lm350-adjustable-
voltage-regulator/) and-tip41tip42/#comment-
332643)
IC2: 7912 negative voltage regulator
D1-D4: 1N4007, 1000V 1A Diodes Tome (http://none) on
TDA2030 transistor amplifier
C1,C2: 2,200uF 35V electrolytic capacitors
circuit with PCB
C3, C4: 0.22uF 50V Ceramic capacitors (https://www.eleccircuit.com/
C5, C6: 100uF 35V Electrolytic capacitors the-otl-amplifier-listen-
comfortably-by-tda2030-
C7, C8: 0.1uF 50V Ceramic capacitors
and-tip41tip42/#comment-
LED1 as you like
332641)
R1: 2.7K 0.5W resistor
Apichet Garaipoom
T1: 220V or 117V to 15VA CT 15V transformer (https://www.eleccircuit.com)
S1: ON-OFF power switch on STK4231II 2 channel
F1: 0.5A Fuse 100w stereo audio amplifier
circuit
How to build (https://www.eleccircuit.com/
2-channel-100w-min-af-
power-amplifier-dual-
This project you can assemble them on the perforated
supplies-
board. It is easy to use, and so cheap. stk4231ii/#comment-
332401)
Cautions
You need to know the pins of all components. You need to
do them correct only. For example, I put the wrong
electrolytic capacitor. When entering the power supply,
causing it to burst. I was shocked too much. But I do not
discontinue this project.
(https://www.eleccircuit.com/wp-
content/uploads/2017/03/7812-pinout-min.png)
But…
7912 Pinout
Related Posts
(https://www.eleccircuit.com
/transformerless-ac-to-dc-
(https://www.eleccircuit.com power-supply-circuits/)
/multi-level-power-supply- Simple transformerless power
supply circuits
with-78xx-series/)
3 Multi voltage power supply
circuits
(https://www.eleccircuit.com
/power-supply-for-audio-
amplifier-multiple-output-
12v-15v-35v/)
Power Supply for Audio Amplifier ,
multiple output 12V, 15V, 35V (https://www.eleccircuit.com
/power-supply-regulator-
15v-15v-1a-by-ic-7815-
7915/)
Dual 15V Power Supply Schematic
With PCB, +15V -15V 1A
(https://www.eleccircuit.com
/0-60-volt-dc-variable-
(https://www.eleccircuit.com
power-supply-using-
/power-supply-splitter-
lm317lm337/)
circuit-using-op-amp/)
0-60V Dual Variable power supply
circuit using LM317&LM337 Power Supply Splitter circuit using
op-amp
Subscribe