Professional Documents
Culture Documents
Non Destructive Test Report - Magnetic Particles Inspection (Mpi)
Non Destructive Test Report - Magnetic Particles Inspection (Mpi)
Customer
Shop Welds
Location IK Factory
IKMI Job #
Magnetic Particle Inspection
Document no.
Specification References: ASME VIII div.1 WELDING QUALITY CONTROL:
NON DESTRUCTIVE TEST REPORT - MAGNETIC PARTICLES INSPECTION (MPI)
↓↓↓ TEST DATA ↓↓↓
Acceptance Criteria: ASME VIII div.1 MPI Fabricator: Isa Khoury Ltd
Reference: ASME V Article 7 IKMI Test Performer:
Test Type: Magnetic Particles Inspection Qualification:
Test Data: See table below Test scope: See table
Test Sequence: The surface to be inspected is cleaned thoroughly to remove all traces of dirt and grease.
A white coloured spray is then applied liberally to the component surface to allow contrast for magnetic liquid. The magnetic
particles liquid is applied onto the white coloured surface. DC Yoke is used to activate the particles and to detect possible
indications. All the applied sprays are removed after inspection.
602673642.xlsx
Any surface-breaking flaws, indications, such as cracks are not found.
Customer Inspector:
602673642.xlsx