Professional Documents
Culture Documents
导杆式柴油打桩锤结构总图
kinds of guide
各种导向装置 Top beam 顶横梁总成
Cylinder 缸锤总成
Oil supply
system
供油系统
Piston 活塞总成
Blocking 塞堵
Pin 穿销
偏 心 轴
月牙销 eccentric shaft
crescent pin
VCresce
油泵压母 oil
pump press nut
nt pin
油泵 oil pump
螺栓
压板 锥销 油管总成
bolt
Press Taper Oil tube
plate pin A
油泵下座密封垫圈
油管总成 total tube
油 泵 下 座 Oil pump under
seat
密封垫圈 seal washer
双头螺栓 stud
挺杆 tappet
压板 pressing plate
垫片 gasket
油管 oil pipe
扁接头
the flat
joint
缸锤总成 cylinder and hammer
螺钉 bolt
缸锤 cylinder hammer
铜套 copper case
开口销 cotter
转子 rotor
黄油嘴 grease nipple
开口销
销轴 hinge pin cotter
六槽螺母
Balance part Six groove nut
平键
Flat key 衬套 lining
锤钩
Hammer
hook
滑轮总成 pulley wheel
滑轮架 pulley yoke
开口销
cotter
绳扣 cord fastener
轴 shaft
制卡
滑轮组件 pulley
轴 shaft
圆管 circle tube
开口销 cotter
螺栓/平垫/弹垫/螺母
Bolt/flat pad/spring
轴 shaft pad/nut
开口销 cotter
制卡 fixed part
销轴 pin shaft
导向装置 guiding device
圆导向装置 circle guide device
长穿销 long through pin
平垫 flat gasket 圆导向 circle guide
弹垫 stretch washer
开口销 cotter
开口销 cotter
开口销 cotter
弹垫 stretch pad
加大圆导向
螺 杆 平垫 flat gasket
Increase 弹性销
screw
circle guide Stretch
pin
机锤与桩架导轨连接方式
The way of hammer connect with pile frame
and guide rail
导轨中心距 330/600 guide rail center distance
14
导轨中心距 600
Guide rail center distance
(300-330)
加大圆导轨规格φ 102
Increase circle guide rail
specifications
桩帽套与打桩锤系法 the method of pile cap
and pile hammer
桩锤 hammer
进油口 oil in
提耳 still
两处放油口(活塞底部)
Two oil drain port
(at the bottom of piston)
桩 pile
燃料供给量的调节
adjustment of fuel supply
空行程位置 Idle motion position
0~0.5
°
转子 rotor