Professional Documents
Culture Documents
ii) number of turns in the secondary coil and primary coil of a self designed
transformer A transformer is an electrical device which is used for changing the
A.C. voltages.
A transformer is most widely used device in both low and high current circuit. As such
transformers are built in an amazing strength of sizes. In electronic, measurement and
control circuits, transformer size may be so small that it weight only a few tens of grams
where as in high voltage power circuits, it may weight hundred of tones.In a transformer, the
electrical energy transfer from one circuit to another circuit takes place without the use of
moving parts.A transformer which increases the voltages is called a step-up transformer .
A transformer which decreases the A.C. voltages is called a step-down transformer .
REQUIREMENTS
The transformer consists of two coils. They are insulated with each other by
insulated material and wound on a common core. For operation at low frequency,
we may have a soft iron. The soft iron core is insulating by joining thin ironstrips
coated with varnish to insulate them to reduce energy losses by eddy
currents.The input circuit is called primary. And the output circuit is called
secondary.
PROCEDURE
1. Take a soft iron rod of cm and cm diameter. Wrap thick paper on it.
3. Wind another coil S of thick enameled copper wire with 400 turns.
4. Both coils are wound over same length of the rod, so that almost the entire flux
produced by current in one is linked to the other.
6. Switch on the current in P and note voltage across the two coils
2. The coil P (to which AC voltage is applied) is Called the primary and coil S (in
which AC is induced) is called the secondary.
3.Since coil S is placed very close to the coil P,the power in the primary is
transferred into the secondary through mutual induction.
4. It is clear from equation 1, that by appropriate choice of the turn ratio i.e.,
Np/Ns, we can obtain a higher voltage or lower voltage in S compared to that in P.
Energy Losses
Following are the major sources of energy loss in a transformer:
1. Copper loss: is the energy loss in the form of heat in the copper coils of a
transformer. This is due to joule heating of conducting wires.
2. Iron loss: is the energy loss in the form of heat in the iron core of the
transformer. This is due to formation of eddy currents in iron core. It is minimized
by taking laminated cores.