Professional Documents
Culture Documents
RD2MANUA
RD2MANUA
Operation manual
Thank you for purchasing this product. Please read this manual carefully before use.
RD2 V1.0
01 04
RP-SMA
02 05
Manual
03 06
III、Graphic Installation
Channel Adjustment
1
Slope Adjustment Nut 0
3 4 5 3 4 5 3 4 5 3 4 5
a、Loosen the two nuts of remote control connector, pick it out with screw from the gap; b、By dial switch, to set the same channel or different channels for two receivers;
b、Insert the metal pole of remote control in the bottom of remote control connector case, If setting the same channel, system will select the receiver with strong signal.
then put the screw back to the gap and fasten the nuts. The installation is OK; If setting different channels, you can choose the receiver by video switch button.
Please Note: When you adjust the revolute joints, be sure to loosen completely. 3、Receive image
Or it will wear and tear the gear of the revolute joints. a、After setting the channel of receiver, you can see the real time video image
from transmitter as below:
2. Install Tripod Connector
1
Connection Point of Holder 0
4、Automatic searching 1 2 3 4 5 1 2 3 4 5 Automatic searching switch
when all the switches to F8 channel, the system opens automatically searching
Tripod Connection Nut function. At this point, no need go through DIP switch FM, Direct operate right button
to search frequency. Press searching button once, the system will automatically
Tripod Connector search for the best channel of the signal and lock it. May continue to operate searching
if dissatisfied.
Notice: Recommend manually dialing FM signal when the distant source signal
Screw Hole
is weak. Automatic search frequency is not easy to lock when the signal is weak.
08 12
a.Pick out the screw of holder connector, then take down connection holder of 5、Charging for the host
remote controller;
a、When the host battery runs low, a voice prompt, and then automatically shut
b.Install the tripod connector, use tripod connection nut to connect tripod holder directly.
down; please charge in time for the host.
charger
Charge Schematic
3. Install Antenna
a. Directional or Omnidirectional antenna which match with RP-SMA can be installed;
12V
IV、Operation
1、Power On/Off 3S\4S\5S\6S
a、After completing the operation above, open the light shield, push the power button to Battery
ON to turn on the machine, the screen will be lighted; Push the power button to OFF to
turn off the machine and the screen.
b、When the power is not sufficient, power indicator will blink and you will hear a
host
warning voice; If no manual Shutdown, system will turn off the machine automatically. Charging Cable
2、Channel Dial
Notice: If you do not use the machine for long time, please charge the
a、After turning on the machine, set channel manually to receive image.
battery regularly to avoid undue discharging and cause the battery damage.
Corresponding channel frequency diagram are as below:
09 13
Specifications
Screen: 7’’ TFT LCD screen/long life, LED backlight
Resolution: 800x480
Brightness: 450 cd/m²
Contrast: 500:1
View Angle: 140/120 degree (Horizontal/Vertical)