Professional Documents
Culture Documents
Fundamentals
Creating Drawings
Enter the name of the drawing model (part, assembly, instance name)
Place a view (or several) of the model. Use a named view to place the main
view, then projected views (typically) for the other views.
Set the display mode of the drawing views using "view", "disp mode", "view
disp". (Don’t rely on the environment setting for hidden line calculations.)
Generate the drawing simultaneously with the part design. Build a few
features, set up views and show dimensions, redefine feature scheme so that
all required dimensions come from the part model, add a few more features,
and so on... Open two windows - one for the part and one for the drawing.
If the drawing is started after the part is complete (or nearly complete)
Use the clean dims option to make the dimensions as legible as possible.
You can also show dimensions by feature, selecting by number and step
through the features, repositioning, switching views, flipping arrows etc. as
needed.
B. Drawing Organization
Driven Dimensions should be layered and named DRIVEN DIMS.
When all views have been created, add another general view in any available
space on the drawing and orient the view to be ISOMETRIC. This is your
http://doc6.diebold.com/opemmancad/fund/credraw/credraw.html 9/17/2004
DIEBOLD - Pro/ENGINEER Help - Creating Drawings Página 2 de 3
extra dimension view. You will use the view to hold all extra dimensions. See
following figure:
When all the dimensions have been properly located, the extra dimensions
view can be erased (NOT deleted).
NOTE: When a view is erased, it is only blanked and can be resumed at any
time. When a view is deleted, it can not be resumed and must be recreated if
needed.
If a dimension is needed that was placed onto the extra dims view, resume the
view and move the dimension from the extra dims view to the desired view
using the "Switch View" command.
C. Miscellaneous Tips
http://doc6.diebold.com/opemmancad/fund/credraw/credraw.html 9/17/2004
DIEBOLD - Pro/ENGINEER Help - Creating Drawings Página 3 de 3
Always include an isometric view if the project drawing standards allow it.
For very complicated drawings of large assemblies you can speed up drawing
repaint by using Erase View to blank views not currently being used. DON'T
forget about these views or you'll have a 10Mb drawing and won't know why.
You can show multiple sheets of a multi-sheet drawing using the "new"
window function. Use CHANGE WINDOW to switch from sheet to sheet.
You can use this function to have look at different areas of the same sheet
without zooming in and out. It is also useful for switching views from one
sheet to another.
Cosmetic thread features may not display hidden in a drawing, but they will
plot out as hidden.
Main Index
March 3, 1997
http://doc6.diebold.com/opemmancad/fund/credraw/credraw.html 9/17/2004