Professional Documents
Culture Documents
Bench LampECU
Power Control CAN LIN
OFF→ON
LINStop command
100ms wait
continuity
For check ECU transmit (period :
wakeup 100ms)
(response feedback) INFOread
between activate.
Response of INFOread
Only for LH ECU.
Stop LIN
transmit for LINstop
inhibit conflict
LIN command Positive response
LIGHTcontrol
Lo,PL,DRL and
TI are able to
(LIN start)
At AHS test, 2 careful points.
1. Keep more than 3.5[s] at following condition consecutively.
*LightingMode = 2 (all LEDs dimmer ON 10~13% duty)
LVLcontrol : Action=0 *No tunnel (all LEDs are ON)
-> Necessary for detect disconnection between LDM and LEDs.
(Requisition is more than 3.2[s] ON and PWM duty 8~92[%])
LVL-LH(RH)response : ActionStatus=0 -> 1
process, so
AHS able to
test during this LVLcontrol : Action=2
time. AHS/LVL
LIGHT function active
Only 1 LED ON
DTC check is (10 LEDs are in tunnel
only for Difficult to test Able to test
DTCread (OFF))
Lobeam failure Check Lobeam- PL/DRL ! PL/DRL
detection. fan rotation (AHS glare)
B2439(=LH) or Positive response of DTCread(=DTC code) speed
/and
B243A(=RH) DTC OK
means above
failure.
These DTCs are ON→OFF
write to flash Wait for
ROM,so keep discharge of
after Lobeam 600mswait
residual charge
turn OFF. in ECU. ECU self check
and new DTC
write are start
OFF→ON after 1.5[s] from
100ms wait power ON.
So finish DTC
Finish less than erase and power
1[s]. OFF during this
DTCerase time, no DTC
written in
flashROM.
Positive response of DTCerase
(DTC clear is
request from
Finish TMC)
ON→OFF