Professional Documents
Culture Documents
a. Xc is larger
b. Xc is smaller
c. Xl is larger
d. Xl is smaller
a. input voltage
b. input frequency
c. input current
c.Magnetic memory
d.All of above
5) Transient Response?? A transient response of a circuit is a temporary change in the way that it behaves due to an external
excitation, that will disappear with time.
Zener diode is connected parallel to the load to make it
6) Zenor diode parallel with load the increase in zener current reverse bias and once the Zener diode exceeds knee
voltage, the voltage across the load becomes constant.
7) Frequency standard of AM receiver is -------------- around 455 kHz..
8) Settling time?? Settling time is the time required for an output to reach and remain within a given error band following some input
stimulus.
A direct data link connects two communication partners. The link is permanently established via a
9) Direct link transmission?? network or a dedicated line and does not need to be connected or disconnected as in the case of a
dial-up line.
10) Multi point transmission?? MultiPoint means any video conference that involves more than two locations that require
telecommunications connections..
a. D flip flop
b. Jk flip flop
c. T flip flop
12) In Half adder which gates is used one AND gate and EX-OR gate...
A Schmitt trigger is a comparator (not exclusively) circuit that makes use of positive feedback (small
13) Schematic trigger??? changes in the input lead to large changes in the output in the same phase) to implement hysteresis (a
fancy word for delayed action) and is used to remove noise from an analog signal while converting it to a
digital one.
14) Between high and low the change in discrete signal????
15) Fan in?? Fan-in refers to the maximum number of input signals that feed the input equations of a logic cell. Fan-out refers to the
maximum number of output signals that are fed by the output equations of a logic cell.
18) Serial transmission?? n telecommunication and data transmission, serial communication is the process of sending data one bit at a
time, sequentially, over a communication channel or computer bus.
20) Equalizing circuit that provide a control each series SCR B. voltage distribution
21) Antenna having high Q???? Antennas with a high Q are narrowband, antennas with a low Q are wideband. The higher the
value of Q, the more sensitive the input impedance is to small changes in frequency.
23) Comparator max output is 5v resistance 25K the upper trigger will be--------?
24) The earth horizontal and vertical component is---------? earth's magnetic field are 0.4×104 T and 0.3×104 T respectively.
26) CMMR?? A high CMRR is required when a differential signal must be amplified in the presence of a possibly large common-mode
input,
a.Motor
b.Machine
c.Relay
d.All
a.Boolean algebra
b.Ladder logic
c.Arthmatic logic
d.All of above