This document contains information about two gear problems. The first problem describes a gear setup with an 80-tooth gear on shaft A that meshes with a 35-tooth gear on shaft B. It is rotating at 500 rev/min. The problem asks to calculate the speed and direction of shaft B, specify the center distance, and describe the effect of an idler wheel.
The second problem describes a double reduction gear setup with gears of varying teeth counts on shafts A, B, C, and D. Shaft A is rotating at 3000 rpm. It asks to calculate the speed and direction of shaft B, the center distance X, and the contact force between gears A and C if shaft A has a torque of 12
Original Description:
Original Title
Problems. Fixed Center Geared Systems hand written
This document contains information about two gear problems. The first problem describes a gear setup with an 80-tooth gear on shaft A that meshes with a 35-tooth gear on shaft B. It is rotating at 500 rev/min. The problem asks to calculate the speed and direction of shaft B, specify the center distance, and describe the effect of an idler wheel.
The second problem describes a double reduction gear setup with gears of varying teeth counts on shafts A, B, C, and D. Shaft A is rotating at 3000 rpm. It asks to calculate the speed and direction of shaft B, the center distance X, and the contact force between gears A and C if shaft A has a torque of 12
This document contains information about two gear problems. The first problem describes a gear setup with an 80-tooth gear on shaft A that meshes with a 35-tooth gear on shaft B. It is rotating at 500 rev/min. The problem asks to calculate the speed and direction of shaft B, specify the center distance, and describe the effect of an idler wheel.
The second problem describes a double reduction gear setup with gears of varying teeth counts on shafts A, B, C, and D. Shaft A is rotating at 3000 rpm. It asks to calculate the speed and direction of shaft B, the center distance X, and the contact force between gears A and C if shaft A has a torque of 12
Shaft A rotates at 500rev/min and carries an 80 tooth 1mm module externally cut spur gear which mates with a 35 tooth wheel on shaft B.
1. Calculate the speed and direction of rotation of shaft B.
2. Specify the centre distance between shaft A and B. 3. Describe the effect of introducing an idler wheel between the gears on shaft A and B.
(-1142rev/min; 57.5mm; only reverses rotation of B wrt A)
Problem 4 Figure 1 shows a double reduction gear where shaft A drives shaft B via the C D compounded pair C-D. If gears A, B, C and D have 25, 85, 80 and 20 teeth C D respectively and the angular speed of shaft A is 3000 rpm, find:
1. the speed and direction of rotation of shaft B;
2. the centre distance X between the primary axis and the layshaft carrying A B the compounded pair if all the gears have a 1.25mm module; 3. the contact force between mating teeth on wheels A and C if shaft A is a A torque of 12Nm. B Figure (+220.6 rev/min; 65.63mm; 768N) 1