Professional Documents
Culture Documents
Department of Education
Region V
SCHOOLS DIVISION OF SORSOGON
I. Introductory Concept
This lesson contains information and learning activities in preparing materials, tools, equipment needed for
installing CCTV Camera
II. Learning Competencies: Prepare unit tools, and workplace for installation and service
Code: TLE_IAEPAS9-12SCEP-DEASS-If-g-47
OBJECTIVE/S
1. Identify the tools and materials used in installing CCTV Camera
2. Enumerate the procedure in using RJ54 Crimper
3. Value the uses and importance of the tools in CCTV Installation
III. Activities
A. Lesson Information
PERSONAL INSTALLER TOOL
Installing security equipment often requires a variety of hand tools to be easy to reach so work can be
done quickly and safely. The most common installation tasks like hanging cameras and running cables require
tools like strippers, knives, screwdrivers, crimpers, and electrical tape
The actual mix and configuration of tools carried is typically optimized for each installer based on the
jobs and equipment they install, and a 'starter' list may include specialty or advanced meters, safety equipment, and
cabling tools not mentioned above.
Screwdriver Set
General purpose set of screwdrivers in various sizes, lengths, and bit driver types. For
general construction, '#2 Phillips' fasteners are common, but security installers often use
a variety of flathead/slot sizes for installing wires into devices, including small 'jeweler'
sized drivers.
TLE-EPAS_Grade10_Q2_LAS2
Medium Framing/Ball Peen Hacksaw
Hammer A handheld hacksaw
Certain tasks are simply with metal / wood cutting blade
resolved through the application is often needed to cut down
of brute force. Medium hammer lengths of conduit, tubing, and
sizes are ideal for security other metallic components like
installs and sized with enough cable trays.
mass to be effective.
ADDITIONAL INFORMATION
Task to do Tools
Example: Cut down the length of conduit, tubing Hacksaw
and other metallic component
1. Mounting of camera to the wall
2. Removing rubber insulator of wire
3. Screw/Unscrew the cover of DVR
4. Attaching of wire and RJ54 socket
5. Cutting of wire in the specific length
C. Task 2
Direction: Arrange the following procedure on How to use the RJ54 CRIMPER by writing
the letters on the space provided. Write your answer on the answer sheet
__________ 1. Remove the cable from the tool and check that all of the pins are down
__________ 2. Untwist and straighten the wires inside of the cable
__________ 3. Insert the wire into the RJ-45 connector
__________ 4. Stick the connector into the crimping part of the tool and squeeze twice
__________ 5. Strip the cable 1 inch (25 mm) from the end.
__________ 6. Cut the wires into an even line ½ inch (13mm) from shearing
__________ 7. Arrange the wires into the right order
V. Evaluation – MULTIPLE CHOICE: Read the questions carefully and choose the letter of the correct answer.
Write your answer on the Answer Sheet
VI.Answer Key
TASK 1 TASK 2 EVALUATION
1. SCREW DRIVER 1. 7 1. D
2. SIDE CUTTER 2. 2 2. A
3. SCREW DRIVER 3. 5 3. C
4. CRIMPER 4. 6 4. B
5. SIDE CUTTER 5. 1 5. B
6. 4
7. 3
Nnnnmmmmmmmmnmm
TLE-EPAS_Grade10_Q2_LAS2