Professional Documents
Culture Documents
WARNING: If the tow bar is connected, do not pressurize the hydraulic systems until
the nose gear steering is locked out. Unwanted tow bar movement can occur.
Note: Pressurize the right system first to prevent fluid transfer between systems.
R ELEC DEMAND pump selector ........................................................................... AUTO
Verify that FAULT light is extinguished prior to selecting remaining hydraulic pumps
to ensure brake system is correctly configured.
C1 and C2 ELEC PRIMARY pump switches ................................................................ON
Verify that the Center 1 FAULT light is extinguished.
The Center 2 FAULT light may stay illuminated until after engine start because of
load shedding.
L ELEC DEMAND pump selector ............................................................................ AUTO
Verify that the FAULT light is extinguished.
C1 and C2 AIR DEMAND pump selectors .............................................................. AUTO
Verify that the FAULT lights are extinguished.
PASS SIGNS panel ............................................................................................................Set
NO ELECTRONICS selector ........................................................................................ON
SEAT BELTS selector ..................................................................................................ON
Verify the memo PASS SIGNS ON message is shown.
Fuel panel ...........................................................................................................................Set
L and R FUEL PUMPS switches ..................................................................................ON
Trim ..................................................................................................................................... Set Verify that the PRESS lights are extinguished.
Stabilizer trim:
Set the trim for takeoff. If the FUEL IN CENTER message shows:
Verify that the trim is in the green band. CENTER FUEL PUMPS switches ..........................................................................ON
Aileron trim: One or both PRESS lights may stay illuminated until after the engine start
Verify the trim is 0 units. because of load shedding.
Rudder trim:
Verify the trim is 0 units. BEACON light switch ..........................................................................................................ON
If any EICAS caution or advisory message(s) is shown:
CANC/RCL switch ..................................................................................................... Push
Verify all caution or advisory message(s) disappears. Press the button as many
times as necessary.
CANC/RCL switch ........................................................................................................... Push
Verify the RECALL indication shows and announce “RECALL”.
Announce the EICAS message(s).