Professional Documents
Culture Documents
2019/06/27 Installation of Power Train Guard on Certain 950L, 950M, 962L, and 962M Medium Wheel Loaders {7150, 7153} (REHS8419)
962M (S/N: K881-UP; EJB1-UP; JYD1-UP; LSE1-UP; RKH1-UP; RCL1-UP; J2S1-UP; F2T1-UP)
962M Z (S/N: SA81-UP)
Introduction
Revision History
Revision Summary of Changes
02 Updated effectivity
Table 1
This Special Instruction provides the necessary information to install the 435-3417 Power Train Guard Group on 950L, 950M, 962L, and 962M
Medium Wheel Loaders.
Do not begin any procedure outlined in this document or order any parts until you have read and understand the information contained in this
instruction.
Safety
Personal injury can result from hydraulic oil pressure and hot
oil.
Make sure all of the attachments have been lowered, and the oil
is cool before removing any components or lines. Remove the
oil filler cap only when the engine is stopped, and the filler cap
is cool enough to touch with your bare hand.
NOTICE
https://sis2.cat.com/#/print-preview/service/%257B%2522title%2522%253A%2522Installation%2520of%2520Power%2520Train%2520Guard%2520on%2520Certain%2520950L%252C%2520950M%252C%2520962… 1/3
1/9/2021 SIS 2.0
3. Release all hydraulic pressure in the system by moving all control levers and releasing pressure on hydraulic tank.
Table 2
Illustration 1 g03686976
The 435-3417 Power Train Guard is made up of three plates that bolt to the bottom of the machine.
Note: The plates are heavy and will require the use of the appropriate lifting device while bolting the plates into position
https://sis2.cat.com/#/print-preview/service/%257B%2522title%2522%253A%2522Installation%2520of%2520Power%2520Train%2520Guard%2520on%2520Certain%2520950L%252C%2520950M%252C%2520962… 2/3
1/9/2021 SIS 2.0
Illustration 2 g03687769
1. Bolt 367-9029 Plate (5) into position on the underside of the engine frame using four 8T-4779 Bolts (4) and four 7X-0583 Hard Washers (1).
Tighten bolts to 240 ± 40 N·m (177 ± 30 lb ft)
2. Mount 367-9033 Plate (6) to the underside of the frame with two 8T-4779 Bolts (4) and two 7X-0583 Hard Washers (1). Tighten bolts to
240 ± 40 N·m (177 ± 30 lb ft)
3. Attach 367-9037 Plate (7) onto 367-9033 Plate (6) with four 8T-4195 Bolts (3) and four 7X-7729 Washers (2). Tighten the bolts to
55 ± 10 N·m (41 ± 7 lb ft).
PIP-10919138
2021/09/01
22:26:14-05:00
i05333189
© 2021 Caterpillar Inc.
Caterpillar:
Confidential Green
https://sis2.cat.com/#/print-preview/service/%257B%2522title%2522%253A%2522Installation%2520of%2520Power%2520Train%2520Guard%2520on%2520Certain%2520950L%252C%2520950M%252C%2520962… 3/3