walls. The rise of dome is 3m. Live and imposed No. of Printed Pages : 05 Roll No. .......................
loads may be taken 3 kN/m2. Use M 20 grade
of concrete and Fe 500 grade of steel. F-71 Section D B. Tech. EXAMINATION, May 2017
7. A retaining wall with the details shown in figure (Sixth Semester)
retains earth of 5m with the top surface being (B. Scheme) horizontal behind the wall. It is also subjected (Main & Re-appear) to 20 kN/m2 surcharge. The soil weighs 16 kN/ CE m3 with angle of repose 30º and allowable CE-302-B bearing capacity 15 kN/m2. The coefficient of friction between the soil and concrete may be REINFORCED CONCRETE DESIGN–II taken as 0.45. Check the stability of the wall as Time : 3 Hours] [Maximum Marks : 75 per IS:456 2000. Before answering the question-paper candidates should ensure that they have been supplied to correct and complete question-paper. No complaint, in this regard, will be entertained after the examination.
Note : Attempt Five questions only which carry
equal marks. However, a student should attempt at least one question from every Section. Use of Indian Standards is allowed. Any data is missing can be suitably assumed. Use of Scientific Calculator is allowed. M-F-71 4 (1-03/29) M-F-71 P.T.O. Section A the footing has been shown in figure. Allowable bearing capacity of soil had been 200 kN/m2. 1. Design a continuous one way slab for a school M 20 grade of concrete and Fe 500 grade of steel building classrooms. The slab is continuous over were used. The designed base slab had 0.96% main beams at 4.5 intervals. Adopt a live load of 4 longitudinal reinforcement. Check whether the kN/m2. Use M20 grade concrete and Fe500 base slab is safe against shear. grade of steel.
2. Design an interior panel with drops of a flat
slab for garrage for loading of 10 kN/m2. The grid of column is 8 × 8m. Use M25 grade of concrete and Fe 415 grade of steel.
Section B
3. Design a footing for a 230 mm thick brick
masonry wall carrying a load of 150 kN/m Section C length under service state condition. Use M20 5. Design a semi circular beam supported on three grade of concrete and Fe 500 grade of steel. equally spaced columns. The centres of the Allowable bearing pressure of soil can be taken columns are on a circular curve of 9 m diameter. as 140 kN/m2 at a depth of 1.25 m. The beam carries designed live and imposed load of 20 kN/m. Use M20 grade of concrete and 4. A combined rectangular footing 850 mm overall Fe 415 grade of steel. depth carries two square columns of 750 mm and 6. Design the reinforced concrete conical dome 600 mm with service axial loads of 1500 kN and for a circular room of 10 m inside diameter. 1000 kN, respectively. The arrnagement made for The dome is supported over 340 mm thick brick M-F-71 2 (1-03/30) M-F-71 3 P.T.O. 8. Use IS : 3370 2009 to design a circular water 8. Use IS : 3370 2009 to design a circular water tank of capacity 400 m3 resting on the ground tank of capacity 400 m3 resting on the ground and having a fixed base condition due to rigid and having a fixed base condition due to rigid joint between the wall and the base slab. M 30 joint between the wall and the base slab. M 30 grade of concrete and Fe 415 grade of steel are grade of concrete and Fe 415 grade of steel are to be used. to be used.