Professional Documents
Culture Documents
No :
UNIT-I
4. Design flexural reinforcement for an RC beam of size 300mm wide and 500mm deep to resist an 14 Marks
ultimate moment of 245 kNm. Assume moderate exposure condition. Use M25 concrete and
Fe 500 grade steel. Adopt Limit State method.
UNIT-III
5. An isolated T-Beam has a flange width of 1000mm. flange thickness of 80mm and effective depth 14 Marks
of 400mm.The rib is 240mm wide and reinforced with 5 bars of 20mm diameter.
Determine the moment of resistance of the Section, If M 20 concrete and Fe 415 steel are used.
The beam is simply supported over a span of 4m.
6. A rectangular beam 250mm wide is subjected to the following at a section 14 Marks
i) Sagging bending moment of 35 kNm.
ii) Shear force of 27 kN.
iii) Torsional moment of 25 kNm.
Use M25 and Fe 415 steel. Design a suitable section and find the reinforcement required in the
section. Sketch the reinforcement details.
Page 1 of 2
Course Code : 15CE1120/2013 R-2015 Reg. No :
UNIT-IV
7. A R.C. Slab is to be provided for a room measuring 5.8m x 5m size. The width of the supporting 14 Marks
2 2
beams is 250 mm, the slab carries Live Load of 4 kN/m and Floor Finish of 1 kN/m . Use
Concrete M 20 and steel grade Fe 500. Design the slab for the corners free to lift condition. Also
draw the plan, section along short and long spans.
8. Design a continuous RC slab for a hall 6 m and 13.5m long. The slab is supported on RCC beams 14 Marks
each 250mm wide which are monolithic. The ends of the slab are supported on walls 300mm wide.
2
Design the slab for a live load of 2.75 kN/m . Assume the weight of roof finishing equal to
2
1.5 kN/m . Use M20 concrete and Fe 415 steel.
UNIT-V
9. Design a short helically reinforced column of unsupported length 3.8 m to carry an axial service 14 Marks
load of 1200 kN. Use M 25 concrete and Fe 250 grade steel. Sketch the reinforcement details.
Assume moderate exposure condition.
10. Design a footing of uniform thickness for a column of size 400mm x 400mm carrying a load of 14 Marks
2
1200 kN. SBC of the soil is 250kN/m . Use M 20 concrete and Fe 415 steel. Sketch the
reinforcement details.
Page 2 of 2