Professional Documents
Culture Documents
PSMsetting
PSMsetting
START-UP PROCEDURE
- 27 -
3. START-UP PROCEDURE START-UP PROCEDURE B-65165E/02
FANUC
S1
S2
Jumper plug
Description
S1 S2
SHORT OPEN With this setting, the servo amplifier module can operate
with the CNC (such as FS0, FS15, FS16, FS18, or PM-
D) designed for operation with interface type A. In this
case the JV*B connector is used.
OPEN SHORT With this setting, the servo amplifier module can operate
with the CNC (such as FS20 or FS21-G) designed for
operation with interface type B. In this case the JS*B
and JF* connectors are used.
NOTE
There is no jumper plug or DIP switch on the three-
axis servo amplifier module. The specification of the
servo amplifier module determines the type (A or B)
of the interface with which it can operate.
- 28 -
B-65165E/02 START-UP PROCEDURE 3. START-UP PROCEDURE
This type of modules do not have a DIP switch except the modules of
which specification drawing numbers are A06B-6072-H***#00xx (D
series spindle amplifier modules) and A06B-6078-H***#H5xx (non-
CE-marked α series spindle amplifier modules).
DIP switch
S7
SW
S1
F2
5A
Switch setting
DIP
(factory-set to the Description
switch
underlined position)
S1 ON If two SPMs are connected to one serial interface
OFF cable, S1 is set to ON in one SPM, and to OFF in
the other.
S2 ON If an analog filter is used at the load meter output,
OFF S2 is set to ON. If not, it is set to OFF.
S3 ON If an analog filter is used at the speedometer
OFF output, S3 is set to ON. If not, it is set to OFF.
S4 S4:ON, S5:OFF Reference switch of Reference switch
S5 NPN type (pull up) (external reference signal
S4:OFF, S5:OFF Reference switch of receive function) setting
PNP type (pull down) for the main spindle
S4:OFF, S5:OFF The external reference
signal receive function.
S6 S6:ON, S7:OFF Reference switch of Reference switch
S7 NPN type (pull up) (external reference signal
S6:OFF, S7:OFF Reference switch of receive function) setting
PNP type (pull down) for the sub-spindle
S6:OFF, S7:OFF The external reference
signal receive function
is not used.
- 29 -