Professional Documents
Culture Documents
Web: www.exceedconsulting.com.au
ABN: 86 107 401 632 Email: info@exceedconsulting.com.au
1.0 INTRODUCTION
One wear samples were submitted for abrasion testing in accordance with ASTM
G65.
2.0 PROCEDURE
2.1 Identification
Exceed ID Client ID
Dry sand abrasion testing was conducted in accordance with ASTM G65
Method A.
Materials Engineering – Materials Selection – Failure Analysis – Visual Inspection – Specialist Testing & Inspection Services
Report No: EXC16 – 161 Page 1 of 3 Revision: C
3.0 RESULTS
R J Dunning A Dunning
B App Sc (Met) MIE Aust C P Eng CMP Adv. Dip. Metallurgy
Materials Engineer
This report has been prepared using the information and samples supplied by the customer. The report
shall not be reproduced except in full. Samples which have been supplied to Exceed Consulting for
the purpose of this investigation will be retained for a period of 1 month from the date of this report.
Should the client wish the samples to be returned or to be retained please advise of the retention
requirements in writing
Materials Engineering – Materials Selection – Failure Analysis – Visual Inspection – Specialist Testing & Inspection Services
Report No: EXC16 – 161 Page 2 of 3 Revision: C
Figure 1: Wear scar of EXC16 – 161
Materials Engineering – Materials Selection – Failure Analysis – Visual Inspection – Specialist Testing & Inspection Services
Report No: EXC16 – 161 Page 3 of 3 Revision: C