Professional Documents
Culture Documents
Name Louis R.
FINAL EXAMINATION
INSTRUCTIONS:
The questions are made to make a real circuit scenario, so simulating in Multisim will is not necessary
to answer the questions.
1. Given the signals VIN1, VIN2 and VIN3 and Vout, determine if the output is
correct. If it is not correct, draw the correct signal and determine the fault in the
circuit.
Signature Over Full Valcos, John
Name Louis R.
The signal that is given in the circuit is incorrect because based on the formula
−RF
vo= (vin1 , vin2 , vin3) the Rf/ Ri will canceled since all resistors are given in 10kΩ
RI
so we would only have a formula vo=−(vin1 , vin2 , vin3) hence, by applying this formula
the first case will only match the correct given output which is the -1V of the output
signal and the rest is incorrect since the calculations did not match the required output
voltage of +3V, -2V, -1V and -4.5V, however when we try analyzing the given signal by
applying a ground in Vin2 then recalculating the given voltage input in Vin1 and Vin3 we
would get the same exact required voltage output. Therefore, by observing the entire
process done by applying a ground to the Vin2 we can have a correct summing
amplifier circuit.
Signature Over Full Valcos, John
Name Louis R.