You are on page 1of 3

Signature Over Full Valcos, John

Name Louis R.

Student Number 2019165101


Program (EE or ECE): ECE
ECE

ACT 4 ECE107L
Signature Over Full Valcos, John
Name Louis R.

Student Number 2019165101


Program (EE or ECE): ECE
ECE
1. Plot the Output Waveform and Input Waveform using 2 Channel Oscilloscope

and compute the Voltage gain of the circuit. Explain the Output Waveform, its

phase and its gain.

The red segment is the input waveform and the green segment is the output

waveform. The Op- amp can be identified as inverting op- amp in which the sine

wave of the input and the output is opposite to each other as it can be observed

in the image shown above. The voltage gain can be computed using the formula

AV= (RF / Rin) for the inverting op amp.

𝑅𝐹
𝐴𝑉 = = 𝟐. 𝟎𝟎𝑽
𝑅𝐼𝑁
Signature Over Full Valcos, John
Name Louis R.

Student Number 2019165101


Program (EE or ECE): ECE
ECE

2. Change the Feedback resistor to 3.5kΩ and Compute the Voltage Gain.

𝑅𝐹 3.5𝑘
𝐴𝑉 = = = 𝟑. 𝟓𝟎𝑽
𝑅𝐼𝑁 1𝑘

3. Change the Feedback resistor to 10kΩ and plot the Output Waveform. Explain

what happened to the Waveform.

As we increase the Feedback resistor to 6kohms to10kohm the output waveform

became a square wave, thus this is due to the feedback which is in closed loop as

well as the op amp is a type of inverting op amp which makes the input to have a

positive (Vout)max and negative (Vout)min.

You might also like