Professional Documents
Culture Documents
com
key C
X=
Y=
D=
X=
Y=
D=
1/3
- You now have to enter 3 points of the circle in the QM-data 200 on
next way.
- The workpiece or piece of pane of which you want the profile or diameter
determination must first be projected on the projection screen.
- The image of the workpiece must be sharpened by using
of the Y-displacement of the table.
- On the projection screen you see a cross of axes, you have to submit your workpiece
move, using the table's Z,X move,
so that the intersection of the axes crosses on the edge of it to be measured
piece. (see fig.)
1/3
WORK INSTRUCTIONS Number: WI.42.091.B
- This is the first measuring point, to save this measuring point in the memory of
the QM data 200, we press the key “LOAD”
2/3
3/3
The QM-data 200 immediately calculates the center point and the diameter
Which immediately pops up on the screen. See example:
X= eg 0.020
Y= eg 1.233
R= eg 3.560
X 00.23
Y 00.56
e.g. Y=0.920
X 0.000
Y 0.920
The specific control limits per thickness can be found on the next page.
WORK INSTRUCTIONS Number: WI.42.091.B
Control limits