Professional Documents
Culture Documents
The display screen is divided into 3 areas, with the largest taking the right hand side and
designated main or working area; the upper left is the performance section, whilst the lower
left is designated monitoring.
To select which page you wish to view in each screen can be achieved in various ways; pre
selection using the F keys is one way in which all three screens can be set, such that pushing
the relevant key will automatically select all 3 screens to the pre-determined views.
Individual screen selection is possible by positioning the cursor in the screen section and right
clicking the mouse button, this will bring up a dialogue box showing the views available for
that particular screen, that required can be selected using the cursor.
There are also buttons on the panel which are labelled with the particular display and which
when pressed will automatically display the allocated page on the working areas.
Working area
The usual display for this area is the position plot, which shows the vessel position, with the
range and rings determined by a pre-set value and displayed in the top right of the screen, but
varied using the cursor and arrows above them. The range, orientation and/or screen centre
can also be adjusted to suit requirements using the drop down cursor dialogue as follows:
View Control –
Mode – changes relative/true
Show – as defined
Grid – changes between rings and square background
Range – select scale
Trace – allows for trace to be switched in showing movement and also selects time
span for thrusters, power, etc. when trends are selected.
Centre Here – Allows centre of screen to be changed to desired position (eg view ahead)
NB. All of the above (except for performance) can also be selected using allocated panel
buttons.