Professional Documents
Culture Documents
ATA28 (https://airbus.work/category/ata28/)
Engine (https://airbus.work/category/engine/)
IAE (https://airbus.work/category/engine/iae/)
https://airbus.work/engine/fuel-used-indicator/ 1/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
1. Item 9 +12 : Fuel used – Engine 1&2
https://airbus.work/engine/fuel-used-indicator/ 2/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
This digital value, resulting from fuel flow integration inside DMC, can vary from 0 to 4536 0
KG, with 10 KG resolution.
The engine identification number is in amber, when the engine is below idle. It is in white,
when it is at, or above, idle.
The fuel used indication is green from flight phase 2, until electrical power is cut off at the
end of the flight. It is automatically reset, when the engine is started on ground.
Case 1: It is normally displayed in green.
Case 2: In case of degraded data (if indication of fuel flow is not valid in flight after 60s) ,
all the digits are dashed, together with the TOTAL indication (FUEL USED 1+2) with two
horizontal amber lines (fuel flow value from the FADEC bus not correctly received by the
DMC in flight).
Case 3: It is replaced by amber XX after a long DMC power supply interruption in flight. In
this case, the fuel used computation stops untill next starting sequence on ground. As a
result, the total fuel used is also replaced by two amber XX.
https://airbus.work/engine/fuel-used-indicator/ 3/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
https://airbus.work/engine/fuel-used-indicator/ 4/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
https://airbus.work/engine/fuel-used-indicator/ 5/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
https://airbus.work/engine/fuel-used-indicator/ 6/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
https://airbus.work/engine/fuel-used-indicator/ 7/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
FADEC :
Each powerplant has a FADEC (Full Authority Digital Engine Control) system.
FADEC, also called the Electronic Engine Control (EEC), is a digital control system that
performs complete engine management
FADEC has two-channel redundancy, with one channel active and one in standby.
The system has a magnetic alternator for an internal power source.
The EEC is designed to operate with the engine not running, the EEC is operational five
seconds after it is electrically powered by A/C 28VDC. The EEC is electrically powered by
the A/C through the EIU. That A/C 28VDC permits :
automatic ground check of the FADEC before engine running
engine starting
powering the EEC (while engine is running below 10 % N2).
As soon as the engine is running at and above 10 % N2 rpm, the dedicated alternator (
magnetic alternator) provides electrical power for the FADEC system.
After an engine shut down the EEC is powered by A/C 28VDC for 5 minutes to allow engine
parameters monitoring.
https://airbus.work/engine/fuel-used-indicator/ 8/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
Add a comment...
Vijay Khot
Excellent info
Like · Reply · 20w
Floor Proximity Emergency Escape Path COND TRIM AIR SYS FAULT
Marking System
https://airbus.work/engine/fuel-used-indicator/ 9/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
Leave a Reply
Search … Search
Recent Posts
Recent Comments
Archives
https://airbus.work/engine/fuel-used-indicator/ 10/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
Categories
ATA21 (https://airbus.work/category/ata21/)
ATA27 (https://airbus.work/category/ata27/)
ATA28 (https://airbus.work/category/ata28/)
ATA29 (https://airbus.work/category/ata29/)
ATA30 (https://airbus.work/category/ata30/)
ATA32 (https://airbus.work/category/ata32/)
ATA33 (https://airbus.work/category/ata33/)
ATA36 (https://airbus.work/category/ata36/)
ATA47 (https://airbus.work/category/ata47/)
ATA49 (https://airbus.work/category/ata49/)
Engine (https://airbus.work/category/engine/)
IAE (https://airbus.work/category/engine/iae/)
https://airbus.work/engine/fuel-used-indicator/ 11/12
8/19/23, 8:00 PM Fuel Used Indicator – My Experience
PW (https://airbus.work/category/engine/pw/)
Meta
Register (https://airbus.work/wp-login.php?action=register)
Log in (https://airbus.work/wp-login.php)
WordPress.org (https://wordpress.org/)
My Experience (https://airbus.work/)
(mailto:)
https://airbus.work/engine/fuel-used-indicator/ 12/12