Professional Documents
Culture Documents
Federal will provide warranty for any unit which is delivered, transported
prepaid, to the Federal factory or designated authorized warranty service
center for examination and such examination reveals a defect in material
and/or workmanship.
This warranty does not cover travel expenses, the cost of specialized
equipment for gaining access to the product, or labor charges for removal
and re-installation of the product. Lamps, flash tubes, or batteries are not
covered under warranty.
This warranty does not extend to any unit which has been subjected to abuse,
misuse, improper installation or which has been inadequately maintained,
nor to units which have problems relating to service or modification at any
facility other than the Federal factory or authorized warranty service
centers.
17 18 19 20
9 10 11 12 13 14 15 16
A B C D E
OFF 1 2 3 4 5 6 7 8
290A2811
Many of these functions, as well as Slide Switch Position 3 - Activates MAN - Will produce peak & hold
some not listed, can be changed to relay 1, 2, & 3, Warn 3 SignalMaster, tone when no other sirens are active.
meet the user’s specific needs. Make the Horn Ring Transfer Relay, and If wail or yelp are active, the tone
sure to take the time to read through enables the Siren. will change to priority for 8-seconds
this manual to understand the full then revert back to the previous
versatility of this product. Auxiliary relay keys A-E activate tone. Horn Ring will do the same if
the corresponding relays and are all it is transferred to the siren.
All warnings and cautions that ap- Push On/Push Off type functions.
pear in the SS2000SM hardware A/H - Will produce Air Horn tone any
installation and maintenance STBY - Turns off sirens time it is pressed.
manual also apply to information
given in this manual. Make sure you RAD- Turns on Radio Rebroadcast. LRC O - SignalMaster Arrow Step
are aware of these warnings and through (Left, Right, Center Out,
cautions before you begin using this PA(Key 11) - Turns on the user sup- Off).
manual and reconfiguring the plied common mic relay to enable the
SS2000SM system. transfer of the radio microphone to WARN - SignalMaster Warn Step
the siren speaker. through (Warn 1, 2, 3, 4 & Off).
WAIL - Wail tone will activate only FAST - SignalMaster Arrows and
when the siren is enabled. In the Warn - fast speed override.
-1-
SS2000SM Features
Function Indicator Sound. powered up. Select "No Siren Active" tone:
• Air Horn.
• Peak & Hold.
• Timer enabled.
• Timer disabled.
-3-
-4-
SECTION IV
OPERATION
SAFETY MESSAGE TO OPERATORS OF
FEDERAL SIGNAL ELECTRONIC SIRENS
AND LIGHT/SOUND SYSTEMS
WARNING • Frequently inspect the speaker to ensure that
it is clear of any obstruction, such as mud or
The lives of people depend on your safe
snow, which will reduce maximum sound
operation of Federal products. It is
output.
important to read and follow all instruc-
tions shipped with the products. In
Signaling Limitations
addition, listed below are some other
important safety instructions and pre- • Be aware that the use of your visual and au-
cautions you should follow: dible signaling devices does not give you the
right to force your way through traffic. Your
Qualifications emergency lights, siren, and actions are
REQUESTING the right-of-way.
• To properly use an electronic siren and
speaker(s): you must have a good understanding • Although your warning system is operating
of general vehicle operation, a high proficiency properly, it may not alert everyone. People
in the use of safety warning equipment, and may not hear, see, or heed your warning signal.
thorough knowledge of state and federal You must recognize this fact and continue
UNIFORM TRAFFIC CODES. driving cautiously.
-5-
MAIN MENU
SmartSiren® SM
17 18 19 20
OFF 1 2 3 4 5 6 7 8
290A2812
-6-
LEVEL 1 (Keyboard)
SmartSiren® SM
17 18 19 20
Function Configuration
SignalMaster Sirens Default
SAVE Indicator
6 Independent Configuration
Mode
Sound Disable
9 10 11 12 13 14 15 16
OFF 1 2 3 4 5 6 7 8
290A2813
-7-
LEVEL 2 (Keys)
SmartSiren® SM
17 18 19 20
Key 11
Slide Aux. Relay Siren
SAVE Switches Keys Disable
&
Pursuit
9 10 11 12 13 14 15 16
OFF 1 2 3 4 5 6 7 8
290A2814
-8-
LEVEL 2 - Slide Switches
SmartSiren® SM
17 18 19 20
OFF 1 2 3 4 5 6 7 8
290A2815
-9-
LEVEL 2 - Slide Switch - Function
SignalMaster SignalMaster SmartSiren® SM SignalMaster SignalMaster
Warn - 1 Warn - 2 Warn - 3 Warn - 4
17 18 19 20
Horn Ring
Key 11 Relay 1 Relay 2 Relay 3 Transfer Siren
SAVE Enable Enable
9 10 11 12 13 14 15 16
Aux. Relay Aux. Relay Aux. Relay Aux. Relay Aux. Relay
A B C D E
OFF 1 2 3 4 5 6 7 8
290A2816
-10-
LEVEL 2 - Aux Relay Keys
SmartSiren® SM
17 18 19 20
SAVE
9 10 11 12 13 14 15 16
Aux. Relay Aux. Relay Aux. Relay Aux. Relay Aux. Relay
A B C D E
OFF 1 2 3 4 5 6 7 8
290A2817
-11-
LEVEL 2 - Aux Relays - Function
SmartSiren® SM
17 18 19 20
9 10 11 12 13 14 15 16
OFF 1 2 3 4 5 6 7 8
290A2818
-12-
LEVEL 2 - Siren Enable/Disable
SmartSiren® SM
17 18 19 20
9 10 11 12 13 14 15 16
Priority
OFF 1 2 3 4 5 6 7 8
290A2819
Level 2 - Siren Enable/Disable is RAD H/L or PRIORITY
where you can enable or disable si-
ren tones, key 11, and radio rebroad- Key 14 can be configured to activate
cast. Key 11
either the High Low tone or the Pri-
ority tone, or neither.
This is also where you choose be- WAIL
tween the High Low tone or the Pri- Turn on key 14 if you want High Low
ority tone, or neither, for key 14.
YELP to activate on key 14.
-13-
LEVEL 2 - Key 11 & Pursuit
SmartSiren® SM
17 18 19 20
Key 11
Key 11
External
SAVE Relay
Horn Ring
Transfer
Activator
9 10 11 12 13 14 15 16
Pursuit Pursuit
Switch Switch Park-Siren
Mode 3 to 0 Mode 3 to 2 Deactivator
OFF 1 2 3 4 5 6 7 8
290A2820
Save LEVEL 2 - Key 11 & Pursuit Turn on key 10 to configure “Key 11” Turn on key 4 to make the pursuit
Switch settings and return to as an external relay activator. switch toggle between modes 3 and
LEVEL 2 (Keys), page 8. 0.
Turn on key 11 to configure “Key 11”
to control the Horn Ring Transfer. Turn on key 5 to make the pursuit
switch toggle between modes 3 and
2.
-14-
LEVEL 3 (Power Up)
SmartSiren® SM
17 18 19 20
SAVE
9 10 11 12 13 14 15 16
OFF 1 2 3 4 5 6 7 8
290A2821
Level 3 - Power Up is where you de- Turn on the keys you want to turn Note
cide what keys should turn on auto- on automatically when the system
matically when the system is turned is powered up. If the sirens are configured to be in-
on. dependent of the slide switch, make
Remember, only one siren or the sure no sirens are selected on power
SAVE RAD key can be selected at a time. up.
If no sirens or RAD is selected, the
Save LEVEL 3 - Power Up settings system will power up in stand-by.
and return to MAIN MENU page 6.
-15-
LEVEL 4 (Horn Ring)
SmartSiren® SM
17 18 19 20
OFF 1 2 3 4 5 6 7 8
290A2822
Level 4 - Horn Ring is where you 8-Second Timeout Activate key 13 if you want YELP to
decide how you want the horn ring be this tone. Activate key 14 if you
to function when it is transferred to Activate key 12 if you want the Horn want PRIORITY.
the siren. Ring Transfer tone to revert back to
the original tone after 8 seconds. No Siren Active Tone
SAVE
Horn Ring Transfer The no siren active tone is the tone
Save LEVEL 4 - Horn Ring settings that will be produced when you have
and return to MAIN MENU page 6. Tone no sirens active, the horn is trans-
ferred, and you press the horn.
The Horn Ring transfer tone is the
tone that will be produced when you Activate key 15 if you want this tone
have a less urgent tone (such as wail) to be Peak & Hold. Activate key 16
already active, the horn is trans- if you want this tone to be Air Horn.
ferred, and you press the horn.
-16-
Worksheet
Level 1
Sirens independent of slide switch Yes No Function Indicator Sound Yes No
SignalMaster Type 6-Lamp 8-Lamp
Level 2 - Keys/Switches
Slide Switch (Circle any combination for each slide switch position.)
Relays Auxiliary Relays Misc. SignalMaster Warn Pattern
Key 11 and Pursuit Switch (Circle one for each of the following.)
-17-
Relay/Device Assignments
List below which controlled devices are connected to which relay.
Additional Notes:
255283C
REV. C 903 Printed in U.S.A.