Professional Documents
Culture Documents
HALO P Smart
Professional Room Air Purifiers
www.erlab.com
Installation Instructions
In this manual we strive to give you as many details as possible to help you installing
smoothly the HALO P.
Our export technical team is anytime at your service to help you further when needed.
Kindly contact:
2
HALO P Smart
Professional Room Air Purifiers
Contents
3
Product Dimensions
Side view
4
Parts Description
H 4 plastic screws ??
5
Installation Procedure
VERY IMPORTANT!
The HALO P shall be located as close as possible to the center of an area of 25 to 30 m2.
Request our HALO P Installation Questionnaire for obtaining our professional advises !
6
Installation Procedure
Installation process
2 possible situations
The room has no false ceiling The room has a false ceiling
Real ceiling
Possible
Max. distance
3m
7
Installation Procedure
Installation steps:
1- If there is a false ceiling , manage a hole of 893 x 593mm to insert later the HALO P
2- Fix the 4 anchors in the real ceiling
3- Attach the 4 metal cables with eye bolts to the anchors
4- Pull down the electrical cable and the RJ45 cable from the ceiling or wall (see picture)
4- Place the HALO P on a table just under where it shall be fixed In the ceiling or false ceiling
5- Connect the electrical cable and the RJ45 cable
6- Approach the HALO P to the area where it shall be installed
7- Fix the cables to the 4 eye bolts located on top of the HALO P
8- Adjust the HALO P at the suitable height (max. 3 m from floor)
9- If there is a false celing, insert the HALO P into the hole and close the gap with the metal
plate supplied.
Electrical cable
RJ 45 cable
HALO P
8
Installation Procedure
RJ 45 cable
HALO P
IMPORTANT
Before installing the Router at the ceiling level, please change its IP address with a
computer into 192.169.0.xxx. Don’t use the same IP address as the one (s) of the HALO P
unit(s) , then set-up a WIFI signal on the Router.
Contact us for any support !
9
Installation Procedure
When the room has a false ceiling, you need to cut out an open area
of 893 x 593mm to insert the Halo
893 mm
10
Installation Procedure
Concrete ceiling
Remove the metal cover by unscrewing Insert the electrical cable and RJ45 through
the 4 screws the metal cover
Fix the electrical cable into the port then tighten it. Replace the metal cover again
Insert the RJ45 into the Ethernet port
Remark: If you don’t connect the Halo to your existing network, please don’t
change the default IP address of the unit.
11
Installation Procedure
Use the 4 eye bolts at each corner of the top of the HALO P
Make sure the cables and anchors can hold at least a total weight of 38 kg
(including the HEPA or ULPA filter), and all the fasteners are secure!
12
Installation Procedure
Concrete
Crete ceiling
The HALO P shall not be more than 3 meters above the floor
Concrete ceiling
false ceiling
Vents
13
Installation of Filters
Turn the below screws clockwise for Remove the old filter
Insert the new filter push the below panel of the filter
tank upward
14
HALO P Smart
Professional Room Air Purifiers