Professional Documents
Culture Documents
E6e7xt36 46 66 6800
E6e7xt36 46 66 6800
press
"START"
key
Check VR ?
STEP 4 STEP 16
Treadmill not back to 0 yes A STEP 11
degree & show E6?
Apply engine modet to rise or Incline Relay damaged
lower on locked treadmill. Then (change new MCB)
let treadmill back to 0 degree Recover
STEP 5 no STEP 17 position
press
STEP 10
"INCLINE"
STEP 9
key Check power cord or
STEP 7 Check incline Motor no
signal ok ?
motor wiring connection
power?
STEP 6 yes yes
about 6 ~10sec yes no no
show E6
STEP 8 STEP 12 Incline motor
Check wiring A
no condition damaged
END
1/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
*Explanation
power switch
STEP 3 :Push "START" to begin work out. STEP 4 :Push "INCLINE", treadmill no react 。
RETURN RETURN
2/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
3/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 5 :Push INCLIN " +" or "--" to adjust inclination. STEP 6 : After 6~10 sec shows "E6".
(Different location shows in different model.)
RETURN RETURN
STEP 7 : Check incline signal STEP 8 : Check upper & lower wiring connection.
(Incline - UP LED on ,decline - DOW N LED on)
RETURN RETURN
4/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
5/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 9 : Check incline motor powercord connection. STEP 10 : Check incline motor powercord or
or check terminal connection as below picture.
RETURN RETURN
STEP 11 : Inclination Relay damaged 。Change new MCB 。 STEP 12 : Incline motor damaged ,change new one.
RETURN RETURN
Incline Motor
6/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
7/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 13 : CNT2 on MCB -bad connection 。 STEP 14 :Check CNT1 connection on MCB.
RETURN RETURN
Stock at lowest
Stock at highest position
position
8/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 16 : Check VR (Use multimeter to check ) STEP 17 : Use incline regulator to help treadmill back to original position.
RETURN RETURN
9/9