Professional Documents
Culture Documents
yes
STEP 4 no Check VR
press STEP 16
"START" STEP 11
key A
Apply engine mode to rise or Incline TRAC brok en
lower on locked treadmill. (change new receiver)
STEP 5 STEP 17 Then let treadmill back to 0 Recover
degree position
press
"INCLINE" STEP 10
key STEP 9
Check power cord or m otor
STEP 7 Check incline Motor no wiring connection
signal ok ? power?
STEP 6 yes yes
about 6 ~10sec yes no no
show E6?
STEP 8 STEP 12
Incline Motor damaged A
no Check wiring (Change new incline
condition motor)
END
1/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
*Explanation
power switch
STEP 3 : Treadmill not back to original position. STEP4 :Push "Start" to begin workout.
RETURN RETURN
2/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
3/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 5 : Push INCLINE " +" or " --" to adjust inclination. STEP 6 : After 6~10 sec shows "E6".
(Different location show s in different m odel.)
RETURN RETURN
STEP 7 : Check incline signal STEP 8 : Check upper & lower wiring connection.
(Incline - UP LED on ,decline - DOW N LED on)
RETURN RETURN
UP LED
DOWN LED
4/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
5/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 9 : Check incline motor powercord connection. STEP 10 : Check incline motor powercord or
or check terminal connection as below picture.
RETURN RETURN
STEP 11 : Incline board TRAC broken 。Change new board. STEP 12 : Incline motor broken ,change new incline motor 。
RETURN RETURN
Incline Motor
6/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
7/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 13 : Incline board J3 conntector in bad connection 。 STEP 14 : Check incline board J2 connection.
RETURN RETURN
J3
J2
Lock at lowest
position
Stop at highest
position
8/9
Treadmill Trouble Shooting Guide(Error code check eliminate)
STEP 16 : Check VR (Apply multimeter to check ) STEP 17 : Use engine mode to back treadmill to original position.
Push "Stop" then push "Incline" buttons.
RETURN RETURN
Push "Stop"
Push INCLINE
"+" or " -"
9/9