Professional Documents
Culture Documents
Embroidery Pattern
overview
pg 1
shopping list
pg 2
beginner basics + terms
pg 3
transferring your pattern
pg 4
threading your needle
securing your stitches
knotting your end
pg 5
finishing the back of your hoop
pg 6
FAQ library
pg 7
pattern template
pg 8
colour
pg 9
stitch guide
pg 10-11
instructions
shopping list
Folded Over - A pattern that calls for 12 strands in some places will use
the “folded over“ method of threading your floss. You will thread all 6
strands through your needle, pull The floss till half way folding it with the
needle at the center and tying the ends together. You can use this
method for any number of even floss strands if you struggle with the
thread coming out from the needle.
Floss Length - How much floss should you cut when your working?
Shorter is better. When your floss tangles up, it can be the most
frustrating part so shorter pieces of floss prevent that. About 10-15” is
a good length.
1. Heat Erase Pen (recommended option) using a printed template tracing through
the fabric using either a window or any light source(light pad on amazon, ipad
screen turned up behind), when finished the pen erases with high heat like an iron,
hair dryer or steam. This option can also be done with a regular pencil but it won't
be erasable.
2. Sulky Stick and Dissolve Paper is paper that prints in your normal printer and sticks
to the fabric. You can stitch through this paper and when you are done it dissolves
in warm water.
3. Carbon Paper - this is a non erasable option that sits on top of your fabric but
under the printed template and when you trace over the printed template the
carbon paper transfers to your fabric leaving the lines.
4. Printing on your home printer directly onto the fabric. Using a full sheet of 8.5x11
sticker paper stuck to the back of your fabric to create a stable printable surface.
Then print onto it like normal.
backing your hoop
This tutorial will guide you in Backing Your Hoop... or check out the instructions
below.
There are many fancy methods for backing your hoop, here is a simple option.
Often I will lay a second layer of fabric once my project is complete to cover all
the messy back and put both layers back into the hoop.
I take a few stitches into the thread once I have cinched the fabric to secure
it, tie the two ends together and cut them short.
You are done!! I hope you love your finished project! Display it however you like, whether it’s hung on
the wall, in a modern hoopla frame or resting on shelf, enjoy!!
faq video library
Click the question to find a video answer to your question.
Colour List
DMC 503 DMC 3822
DMC 223 DMC 3865
DMC 21 DMC 3363
DMC 353
DMC 3827
stitch map