Professional Documents
Culture Documents
This Service Bulletin has been produced in accordance with approved Alternative Procedures to DOA EASA.AP356.
A. SUBJECT:
Replacement of push rod end bearings in elevator and aileron control system.
B. AFFECTED AIRPLANES:
S/N 22001.
C. REASON:
Due to a deviation in the manufacturing process some of the push rod end bearings
(P/N: N3750-401, batch number: 220321 and batch number: 220621) used in elevator
and aileron control system may not meet the required strength specification.
D. REQUIRED ACTION:
1. Replace the push rod end bearings (P/N: N3750-401) in the aileron control according
to AMM, Chapter 27-10. Affected push rod end bearings are shown in Fig. 1
(only RH side is shown, LH side is mirrored).
Fig. 1
2. Replace the push rod end bearings (P/N: N3750-401) in the elevator control according
to AMM, Chapter 27-30. Affected push rod end bearings are shown in Fig. 2.
Fig. 2
3. Check the ailerons and elevator deflections according to AMM Chapter 27-10 and 27-30.
Page 1 of 2
SERVICE BULLETIN Revision: 1
This Service Bulletin has been produced in accordance with approved Alternative Procedures to DOA EASA.AP356.
E. COMPLIANCE:
Before next flight.
I. NECESSARY MATERIAL:
Necessary material will be supplied on request by aircraft manufacturer Aerospool, spol. s r. o.
For material purchase contact the airplane manufacturer’s directly
at spareparts@aerospool.sk.
J. DOCUMENTATION:
AS-AMM-01-000 Aircraft Maintenance Manual, Rev. 6 or later approved revision
K. ENCLOSURES:
None.
L. APPROVAL:
Page 2 of 2