Professional Documents
Culture Documents
5471
BINC Rev: 7/96 Service Documentation
Exploded Drawing
BAG Rev: 6/93 5471
5471 - 2
BINC Rev: 7/96 Service Documentation
Spare Parts List
BAG Rev: 1/96 5471
5471 - 3
BINC Rev: 4/97 Service Documentation
Service Information
BAG Rev: 5/95 5471
Description of shaver
Housing: Thermoplast
Shaving head and swivel frame: Thermoplast
Double shaving foil: Frame construction, "Sixtant"-geometry, Nickel,
Platinum-coated
Double Cutter block: Plastic, 27 cutter blades, 6 mm diameter
Long hair cutter: Integral part of slide (switch). Shaving head and long hair
cutter are working in opposite direction to each other.
General Information
Power supply: Supply by means of one built-in rechargeable battery or by direct mains
supply. A built-in electronic charger controls the supply automatically.
After maximum charging capacity has been reached, the electronic device
switches back to a compensating trickle charge, which maintains capacity.
The most favorable ambient temperatures for shaver functioning is
between + 15 °C and + 35 °C. By no means the temperature should be
below 0 °C or above + 40 °C when charging the shaver.
Technical data
5471 - 4
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 9/94 5471
5471 - 5
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 9/94 5471
Drive unit (10) By means of a tweezers, first press together the snap-on pin
"C". At the same time press a narrow screwdriver between
the drive (10) and the housing bottom (9) (in front of the
snap-on pin), snapping out by turning the screwdriver.
Repeat procedure with the snap-on pin "D". Hence remove
the drive unit by means of the reciprocal lever effect of the
screwdriver.
Head carrier supports Press the housing back (9) on a pad and take off the
(7 + 8) head carrier supports.
Long hair trimmer (14) To be opened with the slider LHT (14). The slider is
to be snapped off upwards at the angle of the hinge
Return the LHT to it's original position in front of the
housing front part Then remove it from the
indentation, turning it 90° horizontally in front of
the housing. (The slider arm snaps out at the lead slot
of the LHT).
5471 - 6
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 9/94 5471
5471 - 7
BINC Rev: 7/96 Service Documentation
Service Information
BAG Rev: 9/94 5471
Housing upper part (13) To be inserted exactly into the bottom (9) in the
eccentric area. The parts are held tightly. With the
other hand, the housing parts are to be pressed
together in the lower area.
Swivel frame (6) To be inserted with the correct sides in head carrier
supports (7 + 8). The eccentric stud must grip exactly
in the lead slot of the swivel frame. When the
switchplate (19) is in position, head lock and long
hair trimmer, the swivel frame (6) has to be secured
in the mid-position.
5471 - 8