Professional Documents
Culture Documents
MEDB00000H9
Revision No:
3
Application of: Directive 2014/90/EU of 23 July 2014 on marine equipment (MED), issued as "Forskrift
om Skipsutstyr" by the Norwegian Maritime Authority. This Certificate is issued by DNV GL AS under the
authority of the Government of the Kingdom of Norway.
This is to certify:
That the Electronic chart display and information system (ECDIS)
Issued to
ChartWorld International Ltd
Limassol, Cyprus
Further details of the equipment and conditions for certification are given overleaf.
...
Approval Engineer:
Vidar Dolonen
Steinar Kristensen Notified Body
No.: 0575 Head of Notified Body
The mark of conformity may only be affixed to the above type approved equipment and a Manufacturer’s Declaration of Conformity
issued when the production-surveillance module (D, E or F) of Annex B of the MED is fully complied with and controlled by a written
inspection agreement with a Notified Body. The product liability rests with the manufacturer or his representative in accordance with
Directive 2014/90/EU.
This certificate is valid for equipment, which is conform to the approved type. The manufacturer shall inform DNV GL AS of any
changes to the approved equipment. This certificate remains valid unless suspended, withdrawn, recalled or cancelled.
Should the specified regulations or standards be amended during the validity of this certificate, the product is to be re-approved
before being placed on board a vessel to which the amended regulations or standards apply.
© DNV GL 2014. DNV GL and the Horizon Graphic are trademarks of DNV GL AS.
Job Id: 344.1-003343-12
Certificate No: MEDB00000H9
Revision No: 3
Product description
eGlobe G2 ECDIS consisting of flat panel computer with integrated display, ethernet and serial line
interfaces. The system is available in configurations with or without support for touch screen
functionality.
Hardware modules:
Unit Description Model name Comment
Panel PC Computer with integrated HD 24T21 CEC-MTD-PNB2 With touch
display unit and embedded or
graphical processor HD 24T21 CEC-MTI-PNBB With touch
or
HD 24T21 CEC-MTD-ANB2 Without touch
or
HD 24T21 CEC-MTI-ANBB Without touch
USB and LAN interfaces Integrated on computer LAN: 2 x RJ 45
motherboard USB*: 4 x USB 2.0
NMEA interface unit PCA100293-1 4xRS485/RS422 ports per
NMEA interface unit,
maximum two units
Options
Keyboard Standard keyboard with G84-5400
trackball
Premium keyboard with KSML92Y
trackball
Trackball eGlobe NSI trackball TSX50YZ
Sensor NMEA interface unit eGlobe SIU-1 1x RS485/RS422 input
connection 4x RS485/RS422 outputs
units External NMEA Com module HT 00262 OPT-A1 4x RS 485/RS 422 ports
Network Ethernet switch EDS-408A-MM-SC-T LAN interfaces:
Switch or EDS-408A-MM-SC-T:
EDS-408A-T 6 x RJ 45 10/100BaseT(X),
2 x SC 100BaseFX
EDS-408A-T:
8 x RJ 45 10/100BaseT(X)
*) USB interfaces may not be used for direct inter-connection to other systems
All units listed above are to be installed in a protected environment, i.e. indoor.
Application/Limitation
The eGlobe G2 ECDIS shall be shall be installed according to Installation, Set-up and Maintenance
Manual.
A dual installation of eGlobe G2 ECDIS is found to comply with the requirements for ECDIS with
Back-up arrangements.
eGlobe G2 ECDIS is found to comply with the requirements for ECDIS in RCDS mode of operation.
eGlobe G2 ECDIS may optionally use mobile internet (3G) connection for download of new charts
and chart updates.
eGlobe G2 ECDIS supports reception of target information from AIS and Radar.
eGlobe G2 ECDIS may optionally be connected to NAVTEX for Maritime Safety Information (MSI).
eGlobe G2 ECDIS cannot be connected to an INS for reception of sensor data.
eGlobe G2 ECDIS supports presentation of radar overlay when received via an ASTERIX*) CAT-240
interface from a radar compliant with the relevant standards of IMO.
Marking of product
The Manufacturer and Type Designation to be applied to the equipment in a clearly visible location
and in addition the equipment shall be marked with serial number, safe distance to magnetic
compass, power consumption and/or supply voltage