Professional Documents
Culture Documents
doubler
Make 1
Make 1
Strake/inlet top
Make 4 from 3mm Depron
Center support for aft wing cover
Make 1
2 Make 2 and laminate
Make 1
Top piece Aft inlet tops
Middle piece Make 2
Make 2 Make 2
Stabilator
Make 2
Drill 1/4" holes both sides
Motor mount Inlet inboard sides Cut hole to fit Cut slot to fit
Bottom piece Make 2 servo used .75" x .75" 1/64" ply motor mount
Make 1 Cut slots to accept tabs doublers on inboard side
on center fuselage bottom (drill 3/16" hole for pivot
bearing tubes)
(1.0" x 1.87")
Make 2 Make 2
Lite-ply doubler
tray spacer
underneath
Inlet
Wing sweep spar box top and bottom
Bulkhead 3
Wing sweep spar box shear webs
Install spacer
spacer here
Mak
Upp 2 from
Mak
L o w 2 f ro m
Make 1
tongue doublers
ing s /8" lite-
ing s /8" lite-
1
wing ply
1
wing ply
a rm
a rm