Professional Documents
Culture Documents
doubler
Make 1
Strake/inlet top
Make 4 from 3mm Depron
Center support for aft wing cover
Make 1
2 Make 2 and laminate
Make 1
Top piece Aft inlet tops
Middle piece Make 2
Make 2 Make 2
Stabilator
Make 2
Drill 1/4" holes both sides
Motor mount Inlet inboard sides Cut hole to fit Cut slot to fit
Bottom piece Make 2 servo used .75" x .75" 1/64" ply motor mount
Make 1 Cut slots to accept tabs doublers on inboard side
on center fuselage bottom (drill 3/16" hole for pivot
bearing tubes)
(1.0" x 1.87")
Make 2
Lite-ply doubler
Make 2
tray spacer
underneath
Inlet
Wing sweep spar box top and bottom
Bulkhead 3
Wing sweep spar box shear webs
0.78" 0.81"
Temporary Temporary Inlet bottoms
Right wing Left wing Inlet Inlet Make 2
Adjust hole spacing on both sides
as required to get proper amount Bulkhead 1 Bulkhead 2
Vertical tail root fairing - Make 4 Rudder control horns
of swing angle in each wing
(dimensions shown are what worked
(make 2 from 1/32" plywood)
Make 1 Make 1
with the HS-81 servo used on prototype).
Note these holes are not necessarily
symmetrical. Wing swing arm spacer
(make 4 from 1/8" lite-ply,
laminate to make 2 pairs)
(0.5" x 1.0")
Install spacer
spacer here
Mak
Upp 2 from
Mak
Low 2 from
Make 1
tongue doublers
ing /8" lite-
ing /8" lite-
swin
1
swin
1
g a r ly
g a r ly
m
p
m
p