You are on page 1of 3

Service

Letter
Service Wärtsilä Nederland B.V.
Engine section Engine type Ref Date Issue Doc. No. Page
Cylinder Liner W26 Service 22-11-'02 01 SL26/1302/03 1(3)

Checking the condition of the


cylinder liners
Background On a very limited number of installations cracks were found in
the landing area of the rim of the liner.
In the long term such cracks could result in operating problems
like water leakage between cylinder liner and engine block.
Present situation has proven to be sensitive for inadequate
de-aeration of jacket coolingwater system, and/or temperature
and pressure fluctuations.

To improve the present situation the construction has been


modified. The modification concerns the following components:
• Cylinder liner
• Axial shim ring (between liner and cylinder block)
• Gas sealing ring
• Tightening procedure of cylinder head
• Machining of the landing face cylinder block according
Service Letter SL26/1302/02.

Recommendation We strongly advise to carry out the following measures at


12.000 hours overhaul (HFO) or 24.000 hours overhaul (MDO)
as follows:

Numbering of The extent of measures is depending on material number of the


cylinder liner liner. The material number can be found on the liner collar on
engine control side (X-mark)

Position of Material number cyl. liner

"X"-mark on
cyl. liner

Wärtsilä Nederland B.V. Telephone: +31 38 425 32 53 All supplies of equipment or services
Po. Box. 10608 Telefax: +31 38 422 35 64 are subject to the Wärtsilä Corp.
8000 GB Zwolle VAT no. NL001449679B01 General Conditions. The company will
Office: Hanzelaan 95 Trade Reg. Zwolle 05047750 gladly supply copies of the General
8017 JE Zwolle Bank: MeesPierson N.V Amsterdam Conditions upon request
The Netherlands Acc. nr. 21 37 63 265
Service
Letter
Service Wärtsilä Nederland B.V.
Engine section Engine type Ref Date Issue Doc. No. Page
Cylinder Liner W26 Service 22-11-'02 01 SL26/1302/03 2(3)

Measures Check all cylinder liners, Mat. no 262601302ZT111 and , Mat. no


262601302ZT122 for cracks by magnetic crack detection method only.

After the crack investigation, different situations can occur.


Each situation (A,B or C) requires a separate instruction as stated below.

A Cylinder liner, Material no. 262601302ZT111 (Part code 1050-001)

1. No cracks found. The cylinder liner can be re-used. Modification


according SL26/1302/02 must be carried out for the entire engine.

Note: only if output Pe < 85% of MCR (Maximum Continuous Rating)

2. No cracks are found and Pe > 85% of the MCR.


The cylinder liner has to be renewed for type 262601302ZT122.
Modification according SL26/1302/02 must be carried out for the entire
engine.

3. If in one or more cylinder liners cracks are found:


Modification according SL26/1302/02 must be carried out for the entire
engine.

Note: Pe > 85% of MCR liner must be changed to 1302ZT122.


Pe < 85% of MCR the cracked liners could be replaced by
262601302ZT111 or 262601302ZT122.

B Cylinder liner, Material no. 262601302ZT112 (Part code 1050-001)

Modification according SL26/1302/02 must be carried out for the entire


engine.and liner must be exchanged for liner type 26260302ZT122.

C Cylinder liner, Material no. 262601302ZT122 (Part code 1050-001)

- If cracks are found the liner has to be renewed by liner of the same type
(Material no. 262601302ZT122)

Note: Only the liners where cracks are observed have to be renewed.

In any case (cracks or not) Modification according SL26/1302/02 must be


carried out for the entire engine.

Wärtsilä Nederland B.V. Telephone: +31 38 425 32 53 All supplies of equipment or services
Po. Box. 10608 Telefax: +31 38 422 35 64 are subject to the Wärtsilä Corp.
8000 GB Zwolle VAT no. NL001449679B01 General Conditions. The company will
Office: Hanzelaan 95 Trade Reg. Zwolle 05047750 gladly supply copies of the General
8017 JE Zwolle Bank: MeesPierson N.V Amsterdam Conditions upon request
The Netherlands Acc. nr. 21 37 63 265
Service
Letter
Service Wärtsilä Nederland B.V.
Engine section Engine type Ref Date Issue Doc. No. Page
Cylinder Liner W26 Service 22-11-'02 01 SL26/1302/03 3(3)

Overview

Instructions For more information and/or modification according SL26/1302/02


contact your nearest Wärtsilä Network Station or send E-mail to:
service.sales.nl@wartsila.com

Tip In view of availability of tools and required materials, for


implementation of this modification it is advised to contact your
nearest Wärtsilä Network Station as early as possible.

Documentation Modified pages for Engine manual and Spare Parts Catalogue will
be made available.

Applies to All W26 engines.

Letter distribution Wärtsilä Network Companies and customers of W26 engines.

Letter validity Until further notice.

Wärtsilä Nederland B.V. Telephone: +31 38 425 32 53 All supplies of equipment or services
Po. Box. 10608 Telefax: +31 38 422 35 64 are subject to the Wärtsilä Corp.
8000 GB Zwolle VAT no. NL001449679B01 General Conditions. The company will
Office: Hanzelaan 95 Trade Reg. Zwolle 05047750 gladly supply copies of the General
8017 JE Zwolle Bank: MeesPierson N.V Amsterdam Conditions upon request
The Netherlands Acc. nr. 21 37 63 265

You might also like