Professional Documents
Culture Documents
Description
Diaoxy Hi-Build Amine Cured Epoxy is an intermediate coat suitable for use where resistance to
fresh water and salt water is required. It gives excellent performance and aids in extending the
life of the paint system with appropriate primer and top coats. It can be used as an undercoat,
intermediate coat or epoxy finish top coat.
Use
It is particularly recommended for protection of steel, concrete, pipelines, harbor, shore
installation and solvent/oil/fuel storage tanks. Suitable for industrial steel structures and water
proofing of tanks.
Technical Data
Classification/Product Type Amine Cured Epoxy Hi-Build Coating
Priming Coat Diaoxy Zinc Phosphate Primer/Etch Primer
Color Reference Assorted
Finish Low to matt Sheen
Components Two
Pack Viscosity 100 + 5 KU at 30°C
Volume Solids 62 + 2% (ISO 3233)
23°C (ISO 3679)
Flash Point
Pot Life 4 Hours at 30°C
Specific Gravity 1.53 + 0.02 at 25°C
Top Coats DiaAcryl 2K PU Paint/Diaoxy Polyamide Cured Epoxy
Shelf Life 01 Year (Depends on Storage Conditions)
Film Thickness and Spreading Rate
Wet Film Thickness 110 to 225 microns
Dry Film Thickness 70 to 140 Microns
Theoretical Spreading Rate 4.2 to 9.0 m2/Ltr./Coat (Assuming No Loss)
No. of Coats (Recommended) 1~2
Surface Preparation
To secure lasting adhesion to the subsequent product all surfaces shall be clean, dry and free
from any contamination.
Substrate Recommended
Carbon Steel Sa 2½ (ISO 8501-1)
Shop Prime Steel Abrasive Swept or Alternatively Blasted to Sa 2 (ISO 8501-1)
Coated Surface Clean, Dry and Undamaged Compatible Coating
Application Method
The product can be applied by
Resistant Guide
Good resistance to
Weather Ability Must be suitably top coated Alkalis splash and spillage of
most common alkalis
Excellent resistance in
immersion for salt water
Xylene Rub 20 Rubs, unaffected Salts when suitably combined
with anti-corrosive
primers
Unaffected by splash or Excellent for immersion
spillage or common in fresh water when
Solvents Water
alcohols, aliphatic and suitably combined with
aromatic hydrocarbons anti-corrosive primers
Toxicity Dry film is non-harmful Suitable for splash and
Acids spillage exposure to
Abrasion Excellent weak inorganic acid
Disclaimer
The information in this data sheet is given to the best of our knowledge based on laboratory
testing and practical experience. However, as the product is often used under conditions beyond
our control, we cannot guarantee anything but the quality of the product itself. We reserve the
right to change the given data without notice.